寒区隧道衬砌电加热试验研究

doi:10.12068/j.issn.1005-3026.2021.07.017

东北大学学报（自然科学版） ›› 2021, Vol. 42 ›› Issue (7): 1025-1031.DOI: 10.12068/j.issn.1005-3026.2021.07.017

寒区隧道衬砌电加热试验研究

王连广，徐宵，李雪

(东北大学资源与土木工程学院，辽宁沈阳110819)

修回日期:2020-09-27 接受日期:2020-09-27 发布日期:2021-07-16
通讯作者: 王连广
作者简介:王连广(1964-)，男，辽宁鞍山人，东北大学教授，博士生导师.
基金资助:
国家自然科学基金青年基金资助项目(51808100)；辽宁省自然科学基金资助项目(2019-ZD_0004，20170540303).

Experimental Study on Electric Heating of Tunnel Lining in Cold Region

WANG Lian-guang， XU Xiao， LI Xue

School of Resources & Civil Engineering， Northeastern University， Shenyang 110819， China.

Revised:2020-09-27 Accepted:2020-09-27 Published:2021-07-16
Contact: XU Xiao
About author:-
Supported by:
-

摘要/Abstract

摘要： 寒区隧道冬季易出现衬砌破损甚至滴水结冰等冻害，为此，除了做保温层外，主动加热系统也是必要的，主动加热系统主要由二次衬砌和保温层间的电热带组成.为了模拟隧道衬砌混凝土表面滴漏水结冰后从负温加热至正温的工况，对负温条件下的混凝土试件进行电加热模型试验研究，包括对单独试件及三联试件进行加热试验.结果表明:在采用长度2m、功率30W、埋置深度10mm的电热带，并选用40mm厚的聚氨酯板作为保温层时，混凝土试件表面温度能够在60min之内从-4℃升高至0℃以上.研究成果可为寒区隧道融冰防冻提供指导.

关键词: 寒区隧道；衬砌结构；电加热系统；升温规律；试验研究

Abstract: In winter， frost damage of tunnel such as lining damaged or even dripping and freezing often occurs in cold region. Therefore， the active heating system is necessary except for the insulation layer. The active heating system is mainly composed of the electric heating belt between the secondary lining and the insulation layer. In order to simulate the heating process of freezing-dripping-water tunnel lining， electric heating model tests on concrete specimen， including single specimen and triple test piece， was conducted from a negative temperature to a positive temperature. The results show that the surface temperature of the concrete specimen can be increased from -4℃ to over 0℃ within 60 minutes， if the electric heating belt with a length of 2 m， power of 30W， embedded depth of 10 mm and the polyurethane board with a thickness of 40mm are used as insulation layer. The research results can provide guidance for ice melting and antifreeze of tunnels in cold regions.

Key words: cold region tunnel; lining structure; electric heating system; temperature rising rule; experimental study

中图分类号:

U457

王连广，徐宵，李雪. 寒区隧道衬砌电加热试验研究[J]. 东北大学学报（自然科学版）, 2021, 42(7): 1025-1031.

WANG Lian-guang， XU Xiao， LI Xue. Experimental Study on Electric Heating of Tunnel Lining in Cold Region[J]. Journal of Northeastern University(Natural Science), 2021, 42(7): 1025-1031.

参考文献

[1]Wu Y M，Xu P，Li W B，et al.Distribution rules and key features for the lining surface temperature of road tunnels in cold regions［J/OL］.Cold Regions Science and Technology，2020，172(2019-12-30)［2020-05-28］.https://doi.org/10.1016/j.coldregions.2019.102979.
[2]Liu W W，Feng Q，Fu S G，et al.Elasto-plastic solution for cold-regional tunnels considering the compound effect of non-uniform frost heave，supporting strength and supporting time［J］.Tunnelling and Underground Space Technology，2018，82:293-302.
[3]Zhang J W，Zhang Y C，Li L，et al.A closed-form solution for the analysis of antifreeze disease fortification length in a permafrost tunnel［J/OL］.Advances in Civil Engineering，2020，2020(2020-02-18)［2020-06-02］.https://doi.org/10.1155/2020/7367954.
[4]罗彦斌，陈建勋，王梦恕，等.基于事件树理论的既有隧道冻害等级划分体系［J］.长安大学学报(自然科学版)，2011，31(6):60-65.(Luo Yan-bin，Chen Jian-xun，Wang Meng-shu，et al.Grade division system of existing tunnel’s freeze injury based on event tree theory［J］.Journal of Chang’an University(Natural Science Edition)，2011，31(6):60-65.)
[5]Luo Y B，Chen J X.Research status and progress of tunnel frost damage［J］.Journal of Traffic and Transportation Engineering(English Edition)，2019，6(3):297-309.
[6]Zhao P Y，Chen J X，Luo Y B，et al.Investigation of the insulation effect of thermal insulation layer in the seasonally frozen region tunnel:a case study in the zuomutai tunnel，China［J/OL］.Advances in Civil Engineering，2019，2019(2019-09-30)［2020-06-02］.https://doi.org/10.1155/2019/4978359.
[7]Li Y Y，Sun Y M，Qiu J L，et al.Moisture absorption characteristics and thermal insulation performance of thermal insulation materials for cold region tunnels［J/OL］.Construction and Building Materials，2020，237(2019-12-11)［2020-04-15］.https://doi.org/10.1016/j.conbuildmat.2019.117765.
[8]杨天娇，王述红，张泽，等.寒区隧道围岩水热力耦合数值分析［J］.东北大学学报(自然科学版)，2019，40(8):1178-1184.(Yang Tian-jiao，Wang Shu-hong，Zhang Ze，et al.Numerical analysis on thermo-hydro-mechanical coupling of surrounding rocks in cold region tunnels［J］.Journal of Northeastern University(Natural Science)，2019，40(8):1178-1184.)
[9]Zhang J，Liu N.Analysis of temperature field of tunnel surrounding rocks in freezing-thawing environment［J］.IOP Conference Series:Materials Science and Engineering，2019，473(1):012017.
[10]Ma Q G，Luo X X，Lai Y M，et al.Numerical investigation on thermal insulation layer of a tunnel in seasonally frozen regions［J］.Applied Thermal Engineering，2018，138:280-291.
[11]Liu H Y，Yuan X P，Xie T C.A damage model for frost heaving pressure in circular rock tunnel under freezing-thawing cycles［J］.Tunnelling and Underground Space Technology，2019，83:401-408.
[12]Feng Q，Liu W W，Jiang B S.Analytical solution for the stress and deformation of rock surrounding a cold-regional tunnel under unequal compression［J］.Cold Regions Science and Technology，2017，139:1-10.
[13]Agrawal K K，Misra R，Agrawal G D，et al.Effect of different design aspects of pipe for earth air tunnel heat exchanger system:a state of art［J］.International Journal of Green Energy，2019，16(8):598-614.
[14]夏才初，范东方，李强，等.寒区隧道保温层铺设长度的计算方法［J］.同济大学学报(自然科学版)，2016，44(9):1363-1370.(Xia Cai-chu，Fan Dong-fang，Li Qiang，et al.An approach for determining length of insulation layer in cold region tunnels［J］.Journal of Tongji University(Natural Science)，2016，44(9):1363-1370.)
[15]Lai J X，Qiu J L，Fan H B，et al.Freeze-proof method and test verification of a cold region tunnel employing electric heat tracing［J］.Tunnelling and Underground Space Technology，2016，60:56-65.
[16]邱军领，赖金星，张广龙，等.季节性寒区隧道主动加热保温防冻方法及其试验［J］.地下空间与工程学报，2017，13(4):982-987.(Qiu Jun-ling，Lai Jin-xing，Zhang Guang-long，et al.A case study on antifreeze of tunnel in seasonal cold-region using the electric heat tracing［J］.Chinese Journal of Underground Space and Engineering，2017，13(4):982-987.)
[17]杨文东，夏杰，谢全敏.高海拔寒区隧道主动保温系统加热功率的计算分析［J］.水利水电技术，2019，50(7):99-104.(Yang Wen-dong，Xia Jie，Xie Quan-min.Calculation and analysis of heating power of active heat preservation system for tunnel in alpine region［J］.Water Resources and Hydropower Engineering，2019，50(7):99-104.)

寒区隧道衬砌电加热试验研究

Experimental Study on Electric Heating of Tunnel Lining in Cold Region

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 12

编辑推荐

Metrics

本文评价

[1]	付腾飞，徐涛，朱万成，王兴伟. 基于多晶离散元法的砂岩三轴压缩损伤特性[J]. 东北大学学报:自然科学版, 2020, 41(7): 968-974.
[2]	王述红，邱伟，高红岩，张紫杉. 数值流形位移法在岩体裂缝扩展中的应用[J]. 东北大学学报:自然科学版, 2019, 40(4): 552-556.
[3]	任凤玉，刘洋，何荣兴，丁航行. 复杂空区群建模及在圈定矿岩移动范围的应用[J]. 东北大学学报:自然科学版, 2018, 39(4): 549-552.
[4]	王薇，张恒文，赵东，张学民. 隧底溶洞对衬砌结构力学行为的影响[J]. 东北大学学报:自然科学版, 2017, 38(9): 1353-1357.
[5]	王述红，高红岩，张紫杉. 基于重度增加法的岩坡破坏过程流形元分析[J]. 东北大学学报:自然科学版, 2016, 37(3): 403-407.
[6]	康虔，王新民，蒲浩，王石. 基于变权-未确知测度理论的岩溶路基稳定性分析[J]. 东北大学学报:自然科学版, 2016, 37(3): 435-439.
[7]	赵兴东，刘杰，徐继涛，温新亮. 基于正交试验设计的某地下储油洞库群支护优化[J]. 东北大学学报:自然科学版, 2015, 36(10): 1453-1456.
[8]	阮云凯，陈剑平，曹琛，闫欢. K-S检验在裂隙岩体统计均质区划分中的应用[J]. 东北大学学报:自然科学版, 2015, 36(10): 1471-1475.
[9]	宋盛渊，王清，陈剑平，李严严. 一种基于裂隙间距的岩体结构统计均质区划分方法[J]. 东北大学学报:自然科学版, 2015, 36(8): 1188-1192.
[10]	郭牡丹，朱浮声，王述红，荣晓洋. 基于结构面特征的优势组划分方法[J]. 东北大学学报:自然科学版, 2014, 35(2): 295-298.
[11]	王述红，饶文杰，关祥祥，穆檄江. 复杂岩体边坡关键块体搜索及开挖支护[J]. 东北大学学报(自然科学版), 2013, 34(7): 1017-1021.
[12]	王述红，李友明，尹宏，侯钦宽. 基于多约束DSI算法的GeoSMA-3D程序改进[J]. 东北大学学报（自然科学版）, 2023, 44(2): 251-257.