文丘里热解反应器结构对流场影响的模拟研究

doi:10.12068/j.issn.1005-3026.2022.06.009

东北大学学报（自然科学版） ›› 2022, Vol. 43 ›› Issue (6): 821-826.DOI: 10.12068/j.issn.1005-3026.2022.06.009

文丘里热解反应器结构对流场影响的模拟研究

吕超^1,2，孙铭赫¹，殷宏鑫¹，刘芳¹

(1. 东北大学秦皇岛分校控制工程学院，河北秦皇岛066004; 2. 东北石油大学秦皇岛校区，河北秦皇岛066004)

修回日期:2021-06-07 接受日期:2021-06-07 发布日期:2022-07-01
通讯作者: 吕超
作者简介:吕超(1985-)，男，辽宁黑山人，东北大学秦皇岛分校副教授.
基金资助:
国家自然科学基金资助项目(51904069); 河北省自然科学基金资助项目(E2019501085)；东北石油大学引导性创新基金资助项目(2018YDQ-09).

Simulation Study on the Effect of Venturi Pyrolysis Reactor Structure on Flow Field

LYU Chao^1,2， SUN Ming-he¹， YIN Hong-xin¹， LIU Fang¹

1. School of Control Engineering， Northeastern University at Qinhuangdao， Qinhuangdao 066004， China; 2. Qinhuangdao Campus， Northeast Petroleum University， Qinhuangdao 066004， China.

Revised:2021-06-07 Accepted:2021-06-07 Published:2022-07-01
Contact: LYU Chao
About author:-
Supported by:
-

摘要/Abstract

摘要： 文丘里热解反应器制备的氧化铈产品存在粒径不均的现象，需要对文丘里热解反应器进行结构优化，进一步强化气固混合效果和倒吸效果，改善粒径分布.利用Fluent19.0软件，采用欧拉-欧拉多相流以及标准k-ε模型研究了9种不同结构的文丘里反应器内部氯化铈热解过程，分析了反应器内部气固混合和倒吸效果.结果表明:引流管长度为35mm，气固混合效果最好;引流管长度45mm，倒吸能力最好.喉管长度为150mm，气固混合效果最好;喉管长度为100mm，倒吸能力最好.扩张段直径与收缩段直径比为2∶2时，气固混合效果最好，倒吸能力最好.

关键词: 文丘里反应器;气固混合;倒吸;氧化铈;数值模拟

Abstract: Due to uneven particle size in cerium oxide products prepared by Venturi pyrolysis reactor， it is necessary to optimize the structure of Venturi pyrolysis reactor to further strengthen the gas-solid mixing effect and the suction effect while improve the particle size distribution. The pyrolysis process of cerium chloride in Venturi reactor with nine different structures was studied by Euler-Euler multiphase flow and standard k-ε model with Fluent19.0 software. The gas-solid mixing and suction effect in Venturi reactor were analyzed. The results showed that the gas-solid mixing effect is best when the length of drainage tube is 35mm. The best suction capacity is obtained when the length of the drainage tube is 45mm. The gas-solid mixing effect is the best if the length of the throat tube is 150mm. The best suction capacity is achieved when the length of the throat tube is 100mm. When the ratio of diameter of expansion section to diameter of contraction section is 2∶2， the gas-solid mixing effect is the best， and the suction capacity is the best.

Key words: Venturi reactor; gas solid mixing; reverse suction; cerium oxide; numerical simulation

中图分类号:

TF351.1

吕超，孙铭赫，殷宏鑫，刘芳. 文丘里热解反应器结构对流场影响的模拟研究[J]. 东北大学学报（自然科学版）, 2022, 43(6): 821-826.

LYU Chao， SUN Ming-he， YIN Hong-xin， LIU Fang. Simulation Study on the Effect of Venturi Pyrolysis Reactor Structure on Flow Field[J]. Journal of Northeastern University(Natural Science), 2022, 43(6): 821-826.

参考文献

[1]Asgharzadeh F，Hashemzadeh A，Rahmani F，et al.Cerium oxide nanoparticles acts as a novel therapeutic agent for ulcerative colitis through anti-oxidative mechanism［J］.Life Sciences，2021，278:1-9.
[2]Chen X C，Li L B，Shan Y H，et al.Synergistic effect of cerium oxide with core-shell structure embedded in porous carbon for high-performance lithium-sulfur batteries［J］.Materials Today Communications，2021，27:1-9.
[3]Wei J J，He C J，Fan C Y，et al.Comparison in the effects of alumina，ceria and silica nanoparticle additives on the combustion and emission characteristics of a modern methanol-diesel dual-fuel CI engine［J］.Energy Conversion and Management，2021，238:235-243.
[4]Tigabu B M.An overview on the photocatalytic degradation of organic pollutants in the presence of cerium oxide(CeO₂)based nanoparticles:a review［J］.Nanoscience and Nanometrology， 2021，7(1):101-112.
[5]刘晓辉.氯化铈溶液热解制备氧化铈的研究［D］.沈阳:东北大学，2011.(Liu Xiao-hui.Study on preparation of ceria by pyrolysis of cerium chloride solution ［D］.Shenyang:Northeastern University，2011.)
[6]吴文远，薛首峰，边雪，等.超细氧化铈制备工艺研究［J］.东北大学学报(自然科学版)，2015，36(6):800-804.(Wu Wen-yuan，Xue Shou-feng，Bian Xue，et al.Study on preparation technology of ultrafine ceria ［J］.Journal of Northeastern University(Natural Science)， 2015，36(6):800-804.)
[7]Musmarra D，Prisciandaro M，Capocelli M，et al.Degradation of ibuprofen by hydrodynamic cavitation:reaction pathways and effect of operational parameters［J］.Ultrasonics Sonochemistry， 2016，29:76-83.
[8]Li R B，Zhang T A，Liu Y，et al.Characteristics of red mud slurry flow in carbonation reactor［J］.Powder Technology，2017，311:66-76.
[9]García J A，Santolaya J L，Lozano A，et al.Experimental characterization of the viscous liquid sprays generated by a Venturi-vortex atomizer［J］.Chemical Engineering & Processing:Process Intensification，2016，105:117-124.
[10]Tsirlis M，Michailidis N.Low-pressure gas atomization of aluminum through a Venturi nozzle［J］.Advanced Powder Technology，2020，31(4):1720-1727.
[11]刘燕，李小龙，张宸，等.稀土氯化物喷雾热解装置雾化效果的物理模拟［J］.东北大学学报(自然科学版)，2019，40(2):218-223.(Liu Yan，Li Xiao-long，Zhang Chen，et al.Physical simulation of atomization effect of rare earth chloride spray pyrolysis device ［J］.Journal of Northeastern University(Natural Science)， 2019，40(2):218-223.)
[12]魏明锐，沃傲波，文华.燃油喷雾初始破碎及二次雾化机理的研究［J］.内燃机学报，2009，27(2):128-133.(Wei Ming-rui，Wo Ao-bo，Wen Hua.Study on the initial breakage and two atomization mechanism of fuel spray［J］.Journal of Internal Combustion Engine，2009，27(2):128-133.)
[13]Khani M，Haghshenasfard M，Etesami N，et al.CO₂absorption using ferrofluids in a Venturi scrubber with uniform magnetic field of a solenoid［J］.Journal of Molecular Liquids，2021，334:1117-1124.
[14]Musketeer S，Verma A，Biswas S，et al.Removal of cement dust particulates via fully submerged self-primed Venturi scrubber［J］.Clean-Soil，Air，Water，2021，49(5):117-124.
[15]王秋良，王振华，吴文勇，等.基于CFD的文丘里施肥器收缩与扩散段结构优化［J］.节水灌溉，2019(9):46-52.(Wang Qiu-liang，Wang Zhen-hua，Wu Wen-yong，et al.Structure optimization of Venturi fertilizer applicator contraction and diffusion section based on CFD ［J］.Water Saving Irrigation， 2019(9):46-52.)
[16]Lv C，Zhang T A，Dou Z H，et al.Numerical simulations of irregular CeO₂ particle size distributions［J］.JOM，2019，71(1):34-39.

文丘里热解反应器结构对流场影响的模拟研究

Simulation Study on the Effect of Venturi Pyrolysis Reactor Structure on Flow Field

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价