蜂窝体蓄热室回收转炉煤气余热可行性研究

doi:10.12068/j.issn.1005-3026.2018.11.018

东北大学学报:自然科学版 ›› 2018, Vol. 39 ›› Issue (11): 1608-1613.DOI: 10.12068/j.issn.1005-3026.2018.11.018

蜂窝体蓄热室回收转炉煤气余热可行性研究

秦勤¹，王奎明¹，于庆波¹，方林²

(1. 东北大学冶金学院，辽宁沈阳110819; 2. 艾欧史密斯(中国)热水器有限公司，江苏南京320100)

收稿日期:2017-07-29 修回日期:2017-07-29 出版日期:2018-11-15 发布日期:2018-11-09
通讯作者: 秦勤
作者简介:冯明杰(1971-)，男，河南禹州人，东北大学副教授; 王恩刚(1962-)，男，辽宁沈阳人，东北大学教授，博士生导师.秦勤(1965-)，女，山东阳谷人，东北大学副教授; 于庆波(1966-)，男，山东莱阳人，东北大学教授，博士生导师.
基金资助:
国家自然科学基金资助项目(51274066).

Feasibility Study on Heat Recovery of Converter Gas by Honeycomb Heat Regenerator

QIN Qin¹， WANG Kui-ming¹， YU Qing-bo¹， FANG Lin²

1. School of Metallurgy， Northeastern University， Shenyang110819， China; 2. A.O.Smith

Received:2017-07-29 Revised:2017-07-29 Online:2018-11-15 Published:2018-11-09
Contact: WANG Kui-ming
About author:-
Supported by:
-

摘要/Abstract

摘要： 从转炉煤气点火源能量出发，研究蜂窝体蓄热室回收转炉煤气中、低温段余热的安全性.建立蜂窝体蓄热室通道物理模型，根据JKR碰撞理论和摩擦学理论分别计算蜂窝体蓄热室内多颗粒相潜在点火源能量.通过最小点火能测定实验台测出常温下3种转炉煤气的最小点火能，修正最小点火能理论计算公式，修正系数为0.909;计算得到3种转炉煤气在着火点(973K)时的最小点火能分别为7.36×10^-7，6.26×10^-7，6.01×10^-7J.与潜在点火源能量对比，结果表明:孔径小于6mm的蜂窝体蓄热室回收转炉煤气中、低温段余热是安全可行的.

关键词: 转炉煤气, 点火能, 蜂窝体蓄热室, 碰撞理论, 摩擦理论

Abstract: Based on the ignition energy of the converter gas， the safety of waste heat recovery from converter gas at middle and low temperature in the honeycomb regenerator is analyzed. A physical model of the channel in the honeycomb regenerator is established. Potential total energy of multi-particle phase in the honeycomb regenerator is calculated by using JKR collision theory and the theory of tribology. Based on the minimum ignition energy(MIE) of converter gas through the MIE experiment platform at room temperature， the experimental correction calculation formula of MIE is revised and the modified coefficient is 0.909.The MIE in three kinds of converter gas at the ignition temperature of 973K is 7.36×10^-7，6.26×10^-7 and 6.01×10^-7J， respectively. Compared with the potential ignition energy， the results show that it is safe and feasible to recover the waste heat from the converter gas at medium-low temperature in the honeycomb regenerator when the bore diameter is smaller than 6mm.

Key words: converter gas, ignition energy, honeycomb heat regenerator, collision theory, friction theory

中图分类号:

X938

秦勤，王奎明，于庆波，方林. 蜂窝体蓄热室回收转炉煤气余热可行性研究[J]. 东北大学学报:自然科学版, 2018, 39(11): 1608-1613.

QIN Qin， WANG Kui-ming， YU Qing-bo， FANG Lin. Feasibility Study on Heat Recovery of Converter Gas by Honeycomb Heat Regenerator[J]. Journal of Northeastern University Natural Science, 2018, 39(11): 1608-1613.

参考文献

[1]于庆波，胡贤忠，刘军祥，等.转炉煤气中温段干法净化和余热回收方法及系统:中国，201210127933.8［P］.2012-08-22.(Yu Qing-bo，Hu Xian-zhong，Liu Jun-xiang，et al.Method and system for dry purification and waste heat recovery of middle temperature section of converter gas:China，201210127933.8［P］.2012-08-22.)
[2]刘改娟，吴仕明.转炉炼钢余热回收技术及工艺方案研究［C］ //冶金循环经济发展论坛论文集.北京:冶金工业出版社，2008:248-249.(Liu Gai-juan，Wu Shi-ming.Research for the processing plan of waste heat recovery in converter of steelmaking［C］ //Proceedings for the Development of Metallurgical Recycling Economy.Beijing:Metallurgical Industry Press，2008:248-249.)
[3]Maruoka N，Akiyama T.Exergy recovery from steelmaking off-gas by latent heat storage for methanol production［J］.Energy，2006，31(10):1632-1642.
[4]Maruoka N，Mizuochi T，Purwanto H，et al.Study for recovering waste heat in the steel making industry using a chemical recuperator［J］.The Iron and Steel Institute of Japan International，2004，44(2):257-262.
[5]Grune J，Breitung W，Kuznetsov M，et al.Flammability limits and burning characteristics of CO-H₂-H₂O-CO₂-N₂ mixtures at elevated temperatures［J］. International Journal of Hydrogen Energy，2015，40(31):9838-9846.
[6]Askari O，Moghaddas A，Alholm A，et al.Laminar burning speed measurement and flame instability study of H₂/CO/air mixtures at high temperatures and pressures using a novel multi-shell model［J］.Combustion and Flame，2016，168:20-31.
[7]Shang R X，Zhang Y，Zhu M M，et al.Laminar flame speed of CO₂ and N₂ diluted H₂/CO/air flames［J］.International Journal of Hydrogen Energy，2016，41(33):15056-15067.
[8]Johnson K L，Kendall K，Roberts A D.Surface energy and the contact of elastic soilds［J］.Proceedings of the Royal Society A，1971，324(1558):301-313.
[9]Thornton C，Ning Z.Theoretical model for the stick/bounce behaviour of adhesive，lastic-plastic spheres［J］.Powder Technology，1998，99(2):154-162.
[10]温诗铸，黄平.摩擦学原理［M］.北京:清华大学出版社，2008:336-354.(Wen Shi-zhu，Huang Ping.Principles of tribology［M］.Beijing:Tsinghua University Press，2008:336-354.)
[11]Valentin L.Popov.contact mechanics and friction:physical principles and applications［M］.Heidelberg:Springer，2010:133-154.
[12]Oesterle B，Petitjean A.Simulation of particle-to-particle interactions in gas-solid flows［J］.International Journal of Multiphase Flow，1993，9(1):199-211.
[13]肖丽.转炉烟尘污泥再利用的研究［D］.重庆:重庆大学，2001.(Xiao Li.Study on reutilization of converter dust and sludge［D］.Chongqing:Chongqing University，2001.)
[14]Williams F A.Combustion theory［M］.New York:The Benjamin/Cummings Publishing Company，1985:265-284.

蜂窝体蓄热室回收转炉煤气余热可行性研究

Feasibility Study on Heat Recovery of Converter Gas by Honeycomb Heat Regenerator

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 9

编辑推荐

Metrics

本文评价

[1]	李刚，刘宗阳，常伟达，张晓宇. 碳素材料粉尘着火爆炸实验研究[J]. 东北大学学报（自然科学版）, 2023, 44(2): 298-304.
[2]	尚融雪，李刚，于立富，董茂林. 高温颗粒引燃转炉煤气的实验研究[J]. 东北大学学报:自然科学版, 2015, 36(9): 1342-1346.
[3]	李新光，钟圣俊，李伟晔，魏玉龙. 火花放电能量精确控制系统研究[J]. 东北大学学报:自然科学版, 2015, 36(2): 162-165.
[4]	任纯力;李新光;王福利;S.RADANDT;. 粉尘云最小点火能数学模型[J]. 东北大学学报(自然科学版), 2009, 30(12): 1702-1705.
[5]	李刚;钟英鹏;苑春苗;陈宝智;. 基于着火敏感性的镁粉防爆方法研究[J]. 东北大学学报(自然科学版), 2007, 28(12): 1775-1778.
[6]	李新光;董洪光;S.Radandt;赫冀成. 粉尘云最小点火能测试方法的比较与分析[J]. 东北大学学报(自然科学版), 2004, 25(1): 44-47.
[7]	李新光;董洪光;S.Radandt;赫冀成. 在三种最小点火能测试装置上对粉尘分散质量的测量[J]. 东北大学学报(自然科学版), 2003, 24(8): 770-773.
[8]	李新光;张平;S.Radandt;赫冀成. 20L球形装置上粉尘湍流速度的测量[J]. 东北大学学报(自然科学版), 2003, 24(10): 952-955.
[9]	黄畅之;费文伯;田秀荣;邓熙帆. 用脉冲激光法引爆并测定粉尘云最小点火能量[J]. 东北大学学报:自然科学版, 1990, 11(2): 150-153.