东北大学学报(自然科学版) ›› 2025, Vol. 46 ›› Issue (4): 78-86.DOI: 10.12068/j.issn.1005-3026.2025.20230268
李刚, 张修鹏, 常伟达, 周伟
收稿日期:
2023-09-15
出版日期:
2025-04-15
发布日期:
2025-07-01
作者简介:
李 刚(1969—),男,河南信阳人,东北大学教授,博士生导师.
基金资助:
Gang LI, Xiu-peng ZHANG, Wei-da CHANG, Wei ZHOU
Received:
2023-09-15
Online:
2025-04-15
Published:
2025-07-01
摘要:
为了解Li(Ni x Co y Mn1-x-y )O2(NCM)锂离子电池热失控释放气体(BVG)在高温环境下引发爆燃的危险性,利用8 L爆炸测试装置和本生灯分别对BVG在不同初始温度θ0(25~120 ℃)下的爆炸特性和层流燃烧速度进行了测试. 同时,利用软件CHEMKIN数值模拟分析了常温和高温条件下层流燃烧速度SL的影响机制. 结果表明,爆炸下限(LFL)随初始温度的升高变化不明显,爆炸上限(UFL)增大;当θ0升高到120 ℃时,最大爆炸压力pmax由0.62 MPa降至0.45 MPa,且与θ0呈指数衰减关系;受正反两方面作用的影响,最大爆炸上升速率(dp/dt)max随θ0的升高有不同程度的降低;极限氧浓度(LOC)从7.39%呈指数下降至7.03%;SL随θ0的升高而增大. 同时发现C2H4和H2含量是影响BVG燃烧及爆炸破坏程度的决定性因素. 研究结果可为NCM锂离子电池热失控引发环境爆燃的危险性评估与防治提供参考.
中图分类号:
李刚, 张修鹏, 常伟达, 周伟. 高温条件下NCM锂离子电池热失控释放气体的爆炸特性[J]. 东北大学学报(自然科学版), 2025, 46(4): 78-86.
Gang LI, Xiu-peng ZHANG, Wei-da CHANG, Wei ZHOU. Explosion Characteristics of NCM Lithium-Ion Battery Vent Gases After Thermal Runaway Under High Temperature Conditions[J]. Journal of Northeastern University(Natural Science), 2025, 46(4): 78-86.
序号 | 时间 | 事故描述 | 事故原因 |
---|---|---|---|
1 | 2010年3月 | 两台iPod Nano音乐播放器过热起火,日本 | 锂离子电池过热[ |
2 | 2011年4月 | 电动出租车起火,中国杭州 | 短路导致电解液燃烧 |
3 | 2013年10月 | 6辆特斯拉Model S新能源汽车起火 | 因碰撞造成电池短路、电池自燃等 |
4 | 2015年4月 | 电动公交车在充电过程中起火,中国深圳 | BMS故障导致蓄电池过充 |
5 | 2017年10月 | 电动汽车起火,奥地利 | 撞车后汽车的锂离子电池起火 |
6 | 2019年4月 | 1个2 MW的储能系统发生爆炸,美国亚利桑那州 | 电池内部缺陷[ |
7 | 2021年4月 | 电化学储能系统发生爆炸,中国北京 | 单体电池内部发生短路[ |
8 | 2023年6月 | 新能源汽车碰撞收费站设施后起火 | 因碰撞造成电池短路、电池自燃等 |
表1 锂离子电池热失控引发的火灾和爆炸事故
Table 1 Fire and explosion accidents caused by thermal runaway of lithium-ion batteries
序号 | 时间 | 事故描述 | 事故原因 |
---|---|---|---|
1 | 2010年3月 | 两台iPod Nano音乐播放器过热起火,日本 | 锂离子电池过热[ |
2 | 2011年4月 | 电动出租车起火,中国杭州 | 短路导致电解液燃烧 |
3 | 2013年10月 | 6辆特斯拉Model S新能源汽车起火 | 因碰撞造成电池短路、电池自燃等 |
4 | 2015年4月 | 电动公交车在充电过程中起火,中国深圳 | BMS故障导致蓄电池过充 |
5 | 2017年10月 | 电动汽车起火,奥地利 | 撞车后汽车的锂离子电池起火 |
6 | 2019年4月 | 1个2 MW的储能系统发生爆炸,美国亚利桑那州 | 电池内部缺陷[ |
7 | 2021年4月 | 电化学储能系统发生爆炸,中国北京 | 单体电池内部发生短路[ |
8 | 2023年6月 | 新能源汽车碰撞收费站设施后起火 | 因碰撞造成电池短路、电池自燃等 |
气体种类 | CO2 | CO | H2 | CH4 | C2H4 |
---|---|---|---|---|---|
体积分数 | 37.3 | 28.9 | 0.7 | 5.4 | 5.7 |
表2 NCM锂离子电池BVG典型组分[11] (battery BVG %)
Table 2 Typical components of NCM lithium-ion
气体种类 | CO2 | CO | H2 | CH4 | C2H4 |
---|---|---|---|---|---|
体积分数 | 37.3 | 28.9 | 0.7 | 5.4 | 5.7 |
温度/℃ | 燃烧速度/(cm·s-1) | ||
---|---|---|---|
H2 | C2H4 | CH4 | |
25 | 311.06 | 9.27 | 37.51 |
120 | 468.34 | 140.07 | 60.61 |
表3 25和120 ℃下H2,C2H4和CH4的最大层流燃烧速度 (C2H4 and CH4 at 25 and 120 °C)
Table 3 Maximum laminar burning velocity of H2
温度/℃ | 燃烧速度/(cm·s-1) | ||
---|---|---|---|
H2 | C2H4 | CH4 | |
25 | 311.06 | 9.27 | 37.51 |
120 | 468.34 | 140.07 | 60.61 |
1 | 张青松, 牛江昊, 赵洋. 不同正极材料锂离子电池热失控产物研究[J]. 消防科学与技术, 2023, 42(5): 598-602. |
Zhang Qing-song, Niu Jiang-hao, Zhao Yang.Research on thermal runaway products of lithiumio batteries with different cathode materials[J]. Fire Science and Technology, 2023,42(5):598-602. | |
2 | Jin Y, Zhao Z X, Miao S, et al. Explosion hazards study of grid-scale lithium-ion battery energy storage station[J]. Journal of Energy Storage, 2021, 42: 102987. |
3 | Zalosh R, Gandhi P, Barowy A. Lithium-ion energy storage battery explosion incidents[J]. Journal of Loss Prevention in the Process Industries, 2021, 72: 104560. |
4 | Wang Q, Ping P, Zhao X, et al. Thermal runaway caused fire and explosion of lithium ion battery[J]. Power Sources, 2012,208: 210-224. |
5 | 潘崇超, 李悦, 李娜, 等. 锂离子电池热失控研究综述与文献计量分析[J]. 科学技术与工程, 2021, 21(24): 10099-10107. |
Pan Chong-chao, Li Yue, Li Na, et al. Research review and bibliometric analysis of thermal runaway of lithium-ion battery[J]. Science Technology and Engineering, 2021, 21(24): 10099-10107. | |
6 | Choi D, Shamim N, Crawford A, et al. Li-ion battery technology for grid application[J]. Journal of Power Sources, 2021, 511: 230419. |
7 | ANSI/CAN/UL 9540A.Standard for test method for evaluating thermal runaway fire propagation in battery energy storage systems: UL 9540A Ed. 4-2019[S].[ul] Underwriters Laboratories, 2019. |
8 | Wang H B, Xu H, Zhang Z L, et al. Fire and explosion characteristics of vent gas from lithium-ion batteries after thermal runaway: a comparative study[J]. eTransportation, 2022, 13: 100190. |
9 | Baird A R, Archibald E J, Marr K C, et al. Explosion hazards from lithium-ion battery vent gas[J]. Journal of Power Sources, 2020, 446: 227257. |
10 | Golubkov A W, Fuchs D, Wagner J, et al. Thermal-runaway experiments on consumer Li-ion batteries with metal-oxide and olivin-type cathodes[J]. RSC Advances, 2014, 4(7): 3633-3642. |
11 | Koch S, Fill A, Birke K P. Comprehensive gas analysis on large scale automotive lithium-ion cells in thermal runaway[J]. Journal of Power Sources, 2018, 398: 106-112. |
12 | CEN. Determination of the explosion limits and the limiting oxygen concentration (LOC) for flammable gases and vapours (British Standard): EN 1839: 2017 [S]. Lordon: British Standards Institution, 2017. |
13 | Huang L J, Wang Y, Pei S F, et al. Effect of elevated pressure on the explosion and flammability limits of methane-air mixtures[J]. Energy, 2019, 186: 115840. |
14 | 尚融雪, 杨悦, 李刚. 高温下掺氢天然气层流预混火焰传播特性[J]. 东北大学学报(自然科学版), 2021, 42(8): 1173-1179. |
Shang Rong-xue, Yang Yue, Li Gang. Propagation of laminar premixed flames of CH4/H2/air mixtures at elevated temperatures[J]. Journal of Northeastern University (Natural Science), 2021, 42(8): 1173-1179. | |
15 | Halter F, Chauveau C, Djebaïli-Chaumeix N, et al. Characterization of the effects of pressure and hydrogen concentration on laminar burning velocities of methane-hydrogen-air mixtures[J]. Proceedings of the Combustion Institute, 2005, 30(1): 201-208. |
16 | Bosschaart K J, de Goey L P H. The laminar burning velocity of flames propagating in mixtures of hydrocarbons and air measured with the heat flux method[J]. Combustion and Flame, 2004, 136(3): 261-269. |
17 | Han X L, Wang Z H, Wang S X, et al. Parametrization of the temperature dependence of laminar burning velocity for methane and ethane flames[J]. Fuel, 2019, 239: 1028-1037. |
18 | Nilsson E J K, van Sprang A, Larfeldt J, et al. The comparative and combined effects of hydrogen addition on the laminar burning velocities of methane and its blends with ethane and propane[J]. Fuel, 2017, 189: 369-376. |
19 | 尚融雪, 杨悦, 高俊豪, 等. 掺氢天然气层流火焰传播速度试验研究[J]. 中国安全科学学报, 2019, 29(11): 103-108. |
Shang Rong-xue, Yang Yue, Gao Jun-hao,et al. Experimental study on laminar flame speed of H2/CH4/air mixtures[J]. China Safety Science Journal, 2019, 29(11): 103-108. | |
20 | Wang Y L, Qi C, Ning Y, et al. Experimental determination of the lower flammability limit and limiting oxygen concentration of propanal/air mixtures under elevated temperatures and pressures[J]. Fuel, 2022, 326: 124882. |
21 | NFPA. Standard on explosion prevention systems. [S]. MA: National Fire Protection Association, 2014. |
22 | Wang Q S, Mao B B, Stoliarov S I, et al. A review of lithium ion battery failure mechanisms and fire prevention strategies[J]. Progress in Energy and Combustion Science, 2019, 73: 95-131. |
[1] | 张培红, 张鑫, 李子建, 姜雪. 双相流细水雾抑制锂离子电池热失控蔓延试验研究[J]. 东北大学学报(自然科学版), 2024, 45(8): 1185-1192. |
[2] | 许开立, 陈西萌, 刘博. 乌龙茶叶粉尘爆炸特性实验研究[J]. 东北大学学报(自然科学版), 2024, 45(7): 1057-1064. |
[3] | 刘芳, 刘彦鹏, 李静东, 卜凡涛. 车载动力电池放电过程健康状态在线估计[J]. 东北大学学报(自然科学版), 2022, 43(11): 1544-1551. |
[4] | 张培红, 袁威, 魏钟原, 李子建. 湿热环境下NCM三元锂离子电池热失控分析[J]. 东北大学学报:自然科学版, 2020, 41(6): 881-887. |
[5] | 李夔宁, 张宏济, 谢翌, 傅春耘. 基于电-热-老化耦合模型的自适应多段恒流充电研究[J]. 东北大学学报:自然科学版, 2019, 40(9): 1323-1329. |
[6] | 耿树东, 翟玉春. 溶胶凝胶辅助高温球磨合成LiCr○xMn2-○x○O4[J]. 东北大学学报:自然科学版, 2017, 38(5): 671-675. |
[7] | 于立富, 李刚, 潘超, 苑春苗. 中国油页岩粉尘爆炸特性实验研究[J]. 东北大学学报:自然科学版, 2016, 37(8): 1203-1206. |
[8] | 袁万颂;田彦文;刘国强;穆萍;. 纳米Zn_2SnO_4的水热合成及电化学性能[J]. 东北大学学报(自然科学版), 2010, 31(9): 1322-1324. |
[9] | 刘国强;刘艳敏;刘光印;田彦文;. LiCoO_2表面沉积ZrO_2涂层的结构和电化学性能[J]. 东北大学学报(自然科学版), 2010, 31(5): 693-695+699. |
[10] | 康晓雪;田彦文;袁万颂;. LiFePO_4的水热合成及电化学性能[J]. 东北大学学报(自然科学版), 2009, 30(9): 1298-1301. |
[11] | 刘丽英;田彦文;徐茶清;翟玉春;. 锂离子电池正极材料锂钒氧的固相合成[J]. 东北大学学报(自然科学版), 2006, 27(4): 434-437. |
[12] | 刘丽英;田彦文;翟玉春;徐茶清;. 锂钒氧化物的制备与电化学性能研究[J]. 东北大学学报(自然科学版), 2006, 27(10): 1130-1133. |
[13] | 徐茶清;田彦文;伍继君;翟玉春. 固相法制备尖晶石型LiMn_2O_4的电化学性能[J]. 东北大学学报(自然科学版), 2005, 26(7): 656-659. |
[14] | 曲涛;田彦文;钟参云;翟玉春. 锂离子电池正极材料LiFePO_4的合成及电化学性能[J]. 东北大学学报(自然科学版), 2005, 26(4): 271-274. |
[15] | 于永丽;翟秀静;王云霞;姚广春. 微波合成LiCoO_2及其结构表征[J]. 东北大学学报(自然科学版), 2005, 26(3): 266-269. |
阅读次数 | ||||||
全文 |
|
|||||
摘要 |
|
|||||