东北大学学报(自然科学版) ›› 2009, Vol. 30 ›› Issue (4): 585-588.DOI: -

• 论著 • 上一篇    下一篇

考虑物料慢变参数的振动压实系统分析

辛丽丽;梁继辉;闻邦椿;   

  1. 东北大学机械工程与自动化学院;沈阳理工大学汽车与交通学院;
  • 收稿日期:2013-06-22 修回日期:2013-06-22 出版日期:2009-04-15 发布日期:2013-06-22
  • 通讯作者: Xin, L.-L.
  • 作者简介:-
  • 基金资助:
    国家自然科学基金资助项目(10572036)

Analysis of vibrating compactor system involving slowly varying parameters of compacted material

Xin, Li-Li (1); Liang, Ji-Hui (2); Wen, Bang-Chun (1)   

  1. (1) School of Mechanical Engineering and Automation, Northeastern University, Shenyang 110004, China; (2) School of Automobile and Traffic Engineering, Shenyang Ligong University, Shenyang 110186, China
  • Received:2013-06-22 Revised:2013-06-22 Online:2009-04-15 Published:2013-06-22
  • Contact: Xin, L.-L.
  • About author:-
  • Supported by:
    -

摘要: 建立含有物料慢变参数的振动压实系统模型,对该模型采用分段线性化方法与渐近法进行求解与仿真分析.利用YZC-1型振动压路机进行现场试验.仿真结果与试验结果对比表明:所建模型正确,计算结果较准确;在压实过程中下车的固有频率随着物料刚度增大及阻尼的减小而逐渐增大;提高激振频率增大激振力可以提高物料的压实效果,但这样会使系统的振动加剧,引起操作人员的身体不适,因此需要合理的选择激振频率;利用混沌运动可以提高压实效果.

关键词: 慢变参数, 振动压实, 分段线性化, 渐近法

Abstract: A model was developed for a vibrating compactor system with slowly varying parameters of compacted material taken into account. The model was solved asymptotically by piecewise linearization with a numerical simulation done analytically. The YZC-1 vibrating compactor was tested in site and the results were compared with simulation results. It was shown that the model is developed properly and calculation results are basically accurate. In the compacting process the natural frequency of the lower part of compactor increases with increasing stiffness of the material to be compacted and increases gradually with decreasing damping. It is necessary to choose rationally the excitation frequency, since increasing the excitation frequency will cause shake that makes operators very uncomfortable though it can increase the exciting force to improve the compacting effect on road material. In addition, the chaotic motion is also able to improve compacting effect.

中图分类号: