煤种对钛磁铁矿直接还原-磁选钛铁分离的影响

doi:10.12068/j.issn.1005-3026.2016.05.023

东北大学学报:自然科学版 ›› 2016, Vol. 37 ›› Issue (5): 716-720.DOI: 10.12068/j.issn.1005-3026.2016.05.023

煤种对钛磁铁矿直接还原-磁选钛铁分离的影响

高恩霞，孙体昌，于春晓，刘志国

(北京科技大学土木与环境工程学院，北京100083)

收稿日期:2014-09-12 修回日期:2014-09-12 出版日期:2016-05-15 发布日期:2016-05-13
通讯作者: 高恩霞
作者简介:高恩霞(1991-)，女，山东临沂人，北京科技大学博士研究生; 孙体昌(1958-)，男，河北保定人，北京科技大学教授，博士生导师.
基金资助:
国家自然科学基金资助项目(51474018).

Effects of Coal Types on the Separation of Iron and Titanium in Titanomagnetite by Direct Reduction-Magnetic Separation

GAO En-xia， SUN Ti-chang， YU Chun-xiao， LIU Zhi-guo

School of Civil and Environmental Engineering， University of Science and Technology Beijing， Beijing 100083， China.

Received:2014-09-12 Revised:2014-09-12 Online:2016-05-15 Published:2016-05-13
Contact: SUN Ti-chang
About author:-
Supported by:
-

摘要/Abstract

摘要： 研究了烟煤和无烟煤对海滨钛磁铁矿直接还原-磁选钛铁分离的影响机理.结果表明，在试验用量范围内，两种煤对还原铁指标的影响规律相近，煤用量低时钛磁铁矿还原不充分.随煤用量增加，被还原的金属铁越来越多，但粒度较小，与其他颗粒嵌布紧密，因此还原铁Fe品位低，TiO₂品位高，铁回收率则先提高后基本不变.所有煤用量下所得金属铁颗粒均纯净.和无烟煤相比，烟煤固定碳较低，还原气氛较弱，但灰分较高，有利于金属铁颗粒的聚集长大；因此相同用量的烟煤为还原剂时，焙烧矿中金属铁颗粒较少，但粒度较大，还原铁中Fe品位较高，铁回收率较低，TiO₂品位较低.

关键词: 海滨钛磁铁矿, 烟煤, 无烟煤, 直接还原, 钛铁分离

Abstract: The influence of bitumite and anthracite on separation of Ti and Fe from beach titanomagnetite ore in the process of direct reduction-magnetic separation was investigated. The experimental results showed that the effects of bitumite and anthracite on iron reduction were similar during the range of experimental dosages. The reduction of titanomagnetite was insufficient when the coal dosages were not enough. With increasing dosages of coals， the quantity of reduced metallic iron increased in the roasted ore but the iron particles became smaller and were embeded closedly with other mineral particles， leading to low Fe grade， high TiO₂ grade in the product. The metallic iron particles obtained by reduction roasting under the experimental conditions were pure. Compared with the same dosages of anthracite， the reducing atmosphere obtained by using bitumite with less content of fixed carbon was weaker but higher ash content of bitumite was good for the growth of metallic iron particles. Hence， the quantity of metallic iron was less but size of particle was larger in the roasted ore. So the direct-reduction iron(DRI) obtained by bitumite had higher Fe grade， lower iron recovery and lower TiO₂ grade than that produced by anthracite.

Key words: beach Titanomagnetite, bitumite, anthracite, direct reduction, titanium and iron separation

中图分类号:

TD925
TF556

高恩霞，孙体昌，于春晓，刘志国. 煤种对钛磁铁矿直接还原-磁选钛铁分离的影响[J]. 东北大学学报:自然科学版, 2016, 37(5): 716-720.

GAO En-xia， SUN Ti-chang， YU Chun-xiao， LIU Zhi-guo. Effects of Coal Types on the Separation of Iron and Titanium in Titanomagnetite by Direct Reduction-Magnetic Separation[J]. Journal of Northeastern University Natural Science, 2016, 37(5): 716-720.

参考文献

[1]刘国栋.海洋矿产资源开发综述［J］.有色金属(矿山部分)，1991(1):6-11.(Liu Guo-dong.Review on the development of oceanic mineral resources［J］.Nonferrous Metals(Mining Section)，1991(1):6-11.)
[2]胡真，张慧，李汉文，等.印尼某海滨砂矿合理选矿工艺流程的研究［J］.矿冶工程，2009，29(6):33-35.(Hu Zhen，Zhang Hui，Li Han-wen，et al.Study on reasonable mineral processing flow sheet of a beach placer in indonesia［J］.Mining and Metallurgical Engineering，2009，29(6):33-35.)
[3]高本恒，王化军，曲媛，等.印尼某海滨砂矿精矿直接还原-磨矿-磁选提铁试验研究［J］.矿冶工程，2012，32(5):44-46.(Gao Ben-heng，Wang Hua-jun，Qu Yuan，et al.Experimental research on extracting iron from beach placer concentrate in indonesia by direct reduction-grinding-magnetic separation［J］.Mining and Metallurgical Engineering，2012，32(5):44-46.)
[4]高恩霞，孙体昌，徐承焱，等.基于还原焙烧的某海滨钛磁铁矿的钛铁分离［J］.金属矿山，2013(11):46-48.)(Gao En-xia，Sun Ti-chang，Xu Cheng-yan，et al.Titaniumand ferrum separation of a seaside titanomagnetite based on reduction roasting［J］.Metal Mine，2013(11):46-48.)
[5]张清岑，邱冠周，肖奇.煤种对低品位铁矿煤基直接还原的影响［J］.中南工业大学学报，1997，28(2):126-129.(Zhang Qing-cen，Qiu Guan-zhou，Xiao Qi.Influence of different types of coal on low grade iron ore by direct reduction roasting［J］.Journal of Central South University of Technology，1997，28(2):126-129.)
[6]Li Y L，Sun T C，Zou A H，et al.Effect of coal levels during direct reduction roasting of high phosphorus oolitic hematite ore in a tunnel kiln［J］.International Journal of Mining Science and Technology，2012，22(3):323-328.
[7]Yu W，Sun T C，Cui Q，et al.Effect of coal type on the reduction and magnetic separation of a high-phosphorus oolitic hematite ore［J］.ISIJ International，2015，55(3):536-543.
[8]Li G H，Shi T M，Rao M J，et al.Beneficiation of nickeliferous laterite by reduction roasting in the presence of sodium sulfate［J］.Minerals Engineering，2012，32(3):19-26.
[9]Jiang M，Sun T C，Liu Z G，et al.Mechanism of sodium sulfate in promoting selective reduction of nickel laterite ore during reduction roasting process［J］.International Journal of Mineral Processing，2013，123(9):32-38.
[10]Chuang H C，Hwang W S，Liu S H.Effects of graphite，SiO₂，and Fe₂O₃ on the crushing strength of direct reduced iron from the carbothermic reduction of residual materials［J］.Materials Transactions，2010，51(3):488-495.

[1]	宋亮，刘善军，毛亚纯，李天子. 基于可见光-近红外光谱的煤种分类方法[J]. 东北大学学报:自然科学版, 2017, 38(10): 1473-1476.
[2]	储满生，赵嘉琦，付小佼，柳政根. 基于气基直接还原-熔分的硼铁矿高效利用新工艺[J]. 东北大学学报:自然科学版, 2016, 37(6): 805-809.
[3]	吕学伟，宋兵，韩可喜，张凯. 添加硅铁对钛精矿直接还原-渣铁分离的影响[J]. 东北大学学报:自然科学版, 2015, 36(2): 223-227.
[4]	姜涛，徐静，关山飞，薛向欣. 高铬型钒钛磁铁矿煤基直接还原研究[J]. 东北大学学报:自然科学版, 2015, 36(1): 77-81.
[5]	孙瑜，董越，郑海燕，沈峰满. 钒钛磁铁矿直接还原试验研究[J]. 东北大学学报:自然科学版, 2015, 36(1): 63-67.
[6]	曹允业，孙体昌，高恩霞，徐承焱. 煤的挥发分对高磷鲕状赤铁矿直接还原焙烧的影响[J]. 东北大学学报:自然科学版, 2014, 35(9): 1346-1349.
[7]	许言，孙体昌，刘志国，徐承焱. 碳酸钠在高磷鲕状赤铁矿直接还原中的作用[J]. 东北大学学报:自然科学版, 2014, 35(7): 1028-1032.
[8]	林海，许晓芳，董颖博，张文通. 深度还原-弱磁选回收稀土尾矿中铁的试验研究[J]. 东北大学学报(自然科学版), 2013, 34(7): 1039-1044.
[9]	许言，孙体昌，刘志国，徐承焱. 某高磷鲕状赤铁矿磷赋存状态及还原焙烧脱磷研究[J]. 东北大学学报（自然科学版）, 2013, 34(11): 1651-1655.
[10]	朱炳秀;魏国;姜鑫;沈峰满;. 低配碳比含碳球团直接还原的实验研究[J]. 东北大学学报(自然科学版), 2012, 33(2): 247-250.
[11]	储满生;方觉. 循环流化床铁矿石直接还原动力学[J]. 东北大学学报:自然科学版, 2002, 23(1): 32-34.
[12]	储满生;方觉. 循环流化床铁矿石直接还原过程动力学分析[J]. 东北大学学报(自然科学版), 2001, 22(2): 140-142.
[13]	余琨. 原矿原煤冶炼──21世纪与高炉竞争的炼铁方式[J]. 东北大学学报:自然科学版, 1998, 19(4): 4--.
[14]	杨松华;史占彪;赵庆杰. 加热速度对煤的气化反应性的影响[J]. 东北大学学报:自然科学版, 1998, 19(2): 4--.
[15]	赵庆杰;赵润波;史占彪. 窑头喷煤强化回转窑还原过程的机理[J]. 东北大学学报:自然科学版, 1994, 15(5): 4--.

煤种对钛磁铁矿直接还原-磁选钛铁分离的影响

Effects of Coal Types on the Separation of Iron and Titanium in Titanomagnetite by Direct Reduction-Magnetic Separation

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价