不同浓度料浆流变特性与混合骨料级配相关性试验

doi:10.12068/j.issn.1005-3026.2020.05.006

东北大学学报:自然科学版 ›› 2020, Vol. 41 ›› Issue (5): 642-648.DOI: 10.12068/j.issn.1005-3026.2020.05.006

不同浓度料浆流变特性与混合骨料级配相关性试验

温震江¹，高谦¹，王永定²，何建元²

(1.北京科技大学金属矿山高效开采与安全教育部重点实验室，北京100083；2.金川集团股份有限公司镍钴资源综合利用国家重点实验室，甘肃金昌737100)

收稿日期:2019-08-27 修回日期:2019-08-27 出版日期:2020-05-15 发布日期:2020-05-15
通讯作者: 温震江
作者简介:温震江(1991-)，男，河南周口人，北京科技大学博士研究生；高谦 (1956-)，男，江苏徐州人，北京科技大学教授.
基金资助:
国家重点研发计划项目(2017YFC0602903).

Experiment on Correlation Between Rheological Properties of Filling Slurry with Different Mass Concentration and Mixed Aggregate Gradation

WEN Zhen-jiang¹， GAO Qian¹， WANG Yong-ding²， HE Jian-yuan²

1.Key Laboratory of High Efficient Mining and Safety of Metal Mine， Ministry of Education， University of Science and Technology Beijing， Beijing 100083， China; 2.National Key Laboratory of Nickel and Cobalt Resources Comprehensive Utilization， Jinchuan Group Co.， Ltd.， Jinchang 737100， China.

Received:2019-08-27 Revised:2019-08-27 Online:2020-05-15 Published:2020-05-15
Contact: GAO Qian
About author:-
Supported by:
-

摘要/Abstract

摘要： 为了探究混合骨料配比及粒径级配对料浆流变特性的影响，首先对矿山充填常用的废石和棒磨砂及其混合骨料进行粒径分析，并得到相应的特征粒径.其次采用流变仪对不同骨料配比、不同质量分数条件下的料浆进行测定，采用H-B流变模型拟合出相应的流变参数.然后对流变参数和流变特性进行分析，并基于最小二乘法研究骨料粒径级配与料浆流变特性的相关性.最后对料浆稳定性进行讨论，并通过建立力学模型确定了混合骨料不沉降离析的临界粒径范围为13.8~21.6mm.试验结果表明:料浆屈服应力和表观黏度均随料浆质量分数的增大而增大；随着剪切速率的增大，料浆流变特性表现出不同的模型特性；料浆流变特性参数与骨料粒径级配的相关性随着特征粒径值的增大而增大.随着质量分数的提高，料浆屈服应力与骨料粒径级配相关性逐渐减弱，而表观黏度与之相反，质量分数和骨料粒径级配对料浆稳定性有很大影响.

关键词: 充填料浆, 流变特性, 混合骨料, 质量分数, 粒径级配, 相关性

Abstract: In order to explore the effects of mixed aggregate ratio and particle size gradation on the rheological properties of the slurry，firstly， the particle size of the waste rock， rod mill sand and the mixture of them commonly used in filling was analyzed， and the corresponding characteristic particle size was obtained.Secondly， the slurry with different aggregate ratios and different mass concentrations was prepared by rheometer. The rheological parameters were fitted by H-B rheological model. Then，the rheological parameters and rheological properties were analyzed， and the correlation between aggregate size distribution and rheological properties of slurry was studied based on least square method.Finally， the stability of slurry is discussed， and the critical particle size range of non-settling segregation of aggregate is 13.8~21.6mm by establishing mechanical model. The test results show that the yield stress and apparent viscosity of the slurry increase with the increase of slurry mass concentration. The rheological properties of slurry show different model characteristics with the increase of shear rate. The correlation between rheological properties parameters of slurry and aggregate particle size distribution increases with the increase of characteristic particle size. With the increase of mass concentration， the correlation between slurry yield stress and aggregate size gradation gradually decreases， while apparent viscosity gradually increases. The mass concentration and aggregate size gradation have a great influence on slurry stability.

Key words: filling slurry, rheological properties, mixed aggregate, mass concentration, particle size gradation, correlation

中图分类号:

TD853
X751

温震江，高谦，王永定，何建元. 不同浓度料浆流变特性与混合骨料级配相关性试验[J]. 东北大学学报:自然科学版, 2020, 41(5): 642-648.

WEN Zhen-jiang， GAO Qian， WANG Yong-ding， HE Jian-yuan. Experiment on Correlation Between Rheological Properties of Filling Slurry with Different Mass Concentration and Mixed Aggregate Gradation[J]. Journal of Northeastern University Natural Science, 2020, 41(5): 642-648.

参考文献

[1]李夕兵，周健，王少锋，等.深部固体资源开采评述与探索［J］.中国有色金属学报，2017，27(6):1236-1262.(Li Xi-bing，Zhou Jian，Wang Shao-feng，et al.Review and practice of deep mining for solid mineral resources［J］.The Chinese Journal of Nonferrous Metals，2017，27(6):1236-1262.)
[2]杨志强，高谦，王永前，等.金川全尾砂-棒磨砂混合充填料胶砂强度与料浆流变特性研究［J］.岩石力学与工程报，2014，33(sup2):3985-3991.(Yang Zhi-qiang，Gao Qian，Wang Yong-qian，et al.Research on filling body strength and rheological properties of mixed filling mortar with unclassified tailings and rod milling sand in Jinchuan mine［J］.Chinese Journal of Rock Mechanics and Engineering，2014，33(sup2):3985-3991.)
[3]杨志强，高谦，王永前，等.废石尾砂混合料浆流变特性及充填采场流动性试验［J］.厦门大学学报(自然科学版)，2017，56(2):294-299.(Yang Zhi-qiang，Gao Qian，Wang Yong-qian，et al.Test study on rheological characteristics for mixed filling slurry including waste rock and tailings and its liquidity in the stope［J］.Journal of Xiamen University (Natural Science)，2017，56(2):294-299.)
[4]张修香，乔登攀.废石-尾砂高浓度充填料浆流变参数的确定［J］.矿冶工程，2018，38(5):11-15.(Zhang Xiu-xiang，Qiao Deng-pan.Determination of rheological parameter of slurry backfill composed of waste rock and sand tailings［J］.Mining and Metallurgical Engineering，2018，38 (5):11-15.)
[5]Santos A C P，Ortiz-Lozano J A，Villegas N，et al.Experimental study about the effects of granular skeleton distribution on the mechanical properties of self compacting concrete (SCC)［J］.Construction & Building Materials，2015，78(78):40-49.
[6]朱梦良，唐小林，刘伟.粗集料对水泥稳定碎石骨架结构形成的影响［J］.交通科学与工程，2010，26(1):1-5.(Zhu Meng-liang，Tang Xiao-lin，Liu Wei.Effect of coarse aggregate on skeleton structure formation of cement stabilized crushed stone［J］.Journal of Transport Science and Engineering，2010，26(1):1-5.)
[7]王洪江，吴爱祥，肖卫国，等.粗粒级膏体充填的技术进展及存在的问题［J］.金属矿山，2009(11):1-5.(Wang Hong-jiang，Wu Ai-xiang，Xiao Wei-guo，et al.The progresses of coarse paste fill technology and its existing problem［J］.Metal Mine，2009(11):1-5.)
[8]吴爱祥，刘晓辉，王洪江，等.考虑时变性的全尾膏体管输阻力计算［J］.中国矿业大学学报，2014，42(5):736-740.(Wu Ai-xiang，Liu Xiao-hui，Wang Hong-jiang，et al.Calculation of resistance in total tailings paste piping transportation based on time-varying behavior［J］.Journal of China University of Mining & Technology，2014，42(5):736-740.)
[9]徐文彬，杨宝贵，杨胜利，等.矸石充填料浆流变特性与颗粒级配相关性试验研究［J］.中南大学学报(自然科学版)，2016，47(4):1282-1289.(Xu Wen-bin，Yang Bao-gui，Yang Sheng-li，et al.Experimental study on correlativity between rheological parameters and grain grading of coal gauge backfill slurry［J］.Journal of Central South University (Science and Technology)，2016，47(4):1282-1289.)
[10]高谦，杨晓炳，温震江，等.基于RSM-BBD的混合骨料充填料浆配比优化［J］.湖南大学学报(自然科学版)，2019，46(6):47-55.(Gao Qian，Yang Xiao-bing，Wen Zhen-jiang，et al.Optimization of proportioning of mixed aggregate filling slurry based on BBD response surface method［J］.Journal of Hunan University(Natural Sciences)，2019，46(6):47-55.)
[11] Zhang J B，An X H，Nie D.Effect of fine aggregate characteristics on the thresholds of self-compacting paste rheological properties［J］.Construction & Building Materials，2016，116:355-365.
[12]赵才智.煤矿新型膏体充填材料性能及其应用研究［D］.徐州:中国矿业大学，2008. (Zhao Cai-zhi.Study on coal mine new paste filling material performance and its application［D］.Xuzhou:China University of Mining and Technology，2008.)
[13]刘志双.充填料浆流变特性及其输送管道磨损研究［D］.北京:中国矿业大学(北京)，2018. (Liu Zhi-shuang.Study on rheological properties of filling slurry and wear of conveying pipeline［D］.Beijing:China University of Mining and Technology(Beijing)，2018.)
[14]赵国彦，杜雪鹏.块石胶结充填颗粒离析机理［J］.中南大学学报(自然科学版)，2012，43(8):3196-3199.(Zhao Guo-yan，Du Xue-peng.Mechanism on particle segregation of rocky cemented fill［J］.Journal of Central South University (Science and Technology)，2012，43(8):3196-3199.)
[15]Jossic L，Magnin A.Drag and stability of objects in a yield stress fluid［J］.AIChE Journal，2001，47(12):2666-2672.
[15]关守平，房少纯.一种新型的区间-粒子群优化算法［J］.东北大学学报(自然科学版)，2012，33(10):1381-1384.(Guan Shou-ping，Fang Shao-chun.A new interval particle swarm optimization algorithm［J］.Journal of Northeastern University(Natural Science)，2012，33(10):1381-1384.)

不同浓度料浆流变特性与混合骨料级配相关性试验

Experiment on Correlation Between Rheological Properties of Filling Slurry with Different Mass Concentration and Mixed Aggregate Gradation

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王宏民，禅亮. 基于频谱相关性分析的齿轮早期磨损诊断[J]. 东北大学学报（自然科学版）, 2023, 44(1): 18-25.
[2]	夏毅敏，柯杰，齐梦学，邓朝辉. TBM掘进参数与不同岩性地层相关性分析[J]. 东北大学学报（自然科学版）, 2021, 42(3): 401-408.
[3]	田勇，安小雪，王昭东，王国栋. 12Cr2Ni4A钢高温真空低压脉冲渗碳工艺[J]. 东北大学学报:自然科学版, 2020, 41(9): 1251-1256.
[4]	季策，马福永. O-OFDM系统中基于相关性分析的改进PTS算法[J]. 东北大学学报:自然科学版, 2019, 40(6): 801-806.
[5]	于冠一，修春亮，赵昌松. 辽宁省环境规制约束下的雾霾脱钩效应分析[J]. 东北大学学报:自然科学版, 2019, 40(3): 435-440.
[6]	杨晓陶，闻英友，陈继洋，赵宏. 基于视觉相关性的无线多媒体传感器网络节能策略[J]. 东北大学学报:自然科学版, 2018, 39(5): 613-618.
[7]	马良，肖萍，王任胜，修世超. 磁流变液中磁性颗粒成链与团聚的临界特征分析[J]. 东北大学学报:自然科学版, 2018, 39(3): 383-388.
[8]	马良，肖萍，王任胜，修世超. 含位形权重的磁流变液孤立链流变剪应力模型[J]. 东北大学学报:自然科学版, 2018, 39(2): 226-231.
[9]	马煜林，张莉萍，刘越，刘兴刚. w(Co)对CB2钢显微组织和力学性能的影响[J]. 东北大学学报:自然科学版, 2018, 39(11): 1598-1603.
[10]	徐礼胜，柴蕊，姚阳，张欠欠. 中心动脉与肱动脉参数的相关性及其回归分析[J]. 东北大学学报:自然科学版, 2017, 38(9): 1230-1234.
[11]	徐久强，赵楠，何璇，赵海. 基于时空影响域地震加权网络的研究[J]. 东北大学学报:自然科学版, 2017, 38(6): 804-808.
[12]	涂宏茂，孙志礼，姬广振，钱云鹏. 考虑失效模式相关性的机械系统可靠性分析[J]. 东北大学学报:自然科学版, 2017, 38(10): 1453-1458.
[13]	苑莹，王梦迪，张同辉，樊晓倩. 沪深300股指期现货市场间相依度测度实证研究[J]. 东北大学学报:自然科学版, 2017, 38(1): 148-152.
[14]	李艺，张爽. 干湿循环作用下混杂纤维混凝土抗硫酸盐侵蚀性能[J]. 东北大学学报:自然科学版, 2016, 37(6): 895-899.
[15]	钱光升，胡筱敏，陈文希，戚重阳. 电凝聚控制MBR膜污染的研究[J]. 东北大学学报:自然科学版, 2016, 37(3): 421-425.