东北大学学报（自然科学版）

东北大学学报:自然科学版 ›› 2017, Vol. 38 ›› Issue (8): 1118-1122.DOI: 10.12068/j.issn.1005-3026.2017.08.012

• 机械工程 • 上一篇    下一篇

机动飞行中转子轴承系统新型碰摩的动力学行为

李小彭， 李加胜， 李木岩， 闻邦椿   

  1. (东北大学 机械工程与自动化学院， 辽宁 沈阳110819)
  • 收稿日期:2016-03-22 修回日期:2016-03-22 出版日期:2017-08-15 发布日期:2017-08-12
  • 通讯作者: 李小彭
  • 作者简介:李小彭(1976-)，男，江西宁都人，东北大学教授，博士生导师； 闻邦椿(1930-)，男，浙江温岭人，东北大学教授，博士生导师，中国科学院院士.
  • 基金资助:
    国家自然科学基金资助项目(51275079).

Dynamics of Rotor Bearing System with New Rubbing Model in Maneuvering Flight

LI Xiao-peng， LI Jia-sheng， LI Mu-yan， WEN Bang-chun   

  1. School of Mechanical Engineering & Automation， Northeastern University， Shenyang 110819， China.
  • Received:2016-03-22 Revised:2016-03-22 Online:2017-08-15 Published:2017-08-12
  • Contact: LI Xiao-peng
  • About author:-
  • Supported by:
    -

RichHTML

0

PDF (PC)

816

摘要： 采用考虑转静间隙变化和叶片数的新型碰摩模型，同时考虑转子在机动飞行条件下引起的机动载荷和滚动轴承非线性赫兹接触力，建立了转子-滚动轴承-碰摩耦合系统非线性动力学微分方程.利用数值方法分析了转速和机动载荷对系统动力学行为的影响.研究结果表明:机动飞行条件下碰摩转子系统亚谐波共振幅值增加;低速时，碰摩主要激发高频振动，高速时则激发低频振动;机动载荷增加使转子系统振动增大，从而引起转子与定子间的碰摩.

关键词: 机动飞行, 碰摩模型, 转子-轴承-碰摩耦合, 动力学模型, 非线性振动

Abstract: A new rubbing model is proposed， which considers the change in rotor-stator clearance and the number of blades. The maneuver load caused by maneuvering flight and nonlinear Hertz contact force of rolling bearing are also considered. The nonlinear dynamic differential equation of rotor-ball bearings-rubbing coupling system is established by using the finite element method. The effects of rotational speed and maneuver load on the dynamic behavior of the system are analyzed. It is shown that the sub-harmonic resonance of rotor system increases under the rubbing fault. The high frequency components are excited by the rubbing fault at lower speeds， while the low frequency components are excited by the rubbing fault at high speeds. The maneuver load makes the rotor’s vibration increase， which may result in the rubbing fault between the rotor and the stator.

Key words: maneuvering flight, rubbing model, rotor-bearing-rubbing coupling, dynamic model, nonlinear vibration

中图分类号: