东北大学学报（自然科学版）

东北大学学报(自然科学版) ›› 2009, Vol. 30 ›› Issue (8): 1163-1165+1173.DOI: -

• 论著 • 上一篇    下一篇

转杯法高炉渣粒化实验研究

于庆波;刘军祥;窦晨曦;胡贤忠;   

  1. 东北大学国家环境保护生态工业重点实验室;
  • 收稿日期:2013-06-22 修回日期:2013-06-22 出版日期:2009-08-15 发布日期:2013-06-22
  • 通讯作者: Yu, Q.-B.
  • 作者简介:-
  • 基金资助:
    国家高技术研究发展计划项目(2006AA05Z209);;

Dry granulation experiment of blast furnace slag by rotary cup atomizer

Yu, Qing-Bo (1); Liu, Jun-Xiang (1); Dou, Chen-Xi (1); Hu, Xian-Zhong (1)   

  1. (1) SEPA Key Laboratory on Eco-Industry, Northeastern University, Shenyang 110004, China
  • Received:2013-06-22 Revised:2013-06-22 Online:2009-08-15 Published:2013-06-22
  • Contact: Yu, Q.-B.
  • About author:-
  • Supported by:
    -

RichHTML

1

PDF (PC)

1269

摘要： 由于目前采用的水淬法工艺不能有效地回收利用高炉渣中的能量,因此针对转杯法炉渣粒化工艺,研究了转杯转速、直径和熔渣温度对破碎粒化后渣粒的平均直径和质量分布的影响规律.结果表明:渣粒的平均直径随转速的提高而减小;增大转速,渣粒将远离转杯,其质量分布更均匀.当转杯的转速小于1 000 r/min时,渣粒的平均直径随转杯直径的增大而减小,当转杯的转速大于1 000 r/min时,渣粒的平均直径几乎不随转杯直径变化.熔渣温度对渣粒平均直径和质量分布没有影响.

关键词: 高炉渣, 余热回收, 干法粒化, 转杯法粒化

Abstract: A dry granulation experiment was done by means of a rotary cup atomizer for blast furnace slag instead of the currently used water quenching process because it is unable to efficiently recover the waste heat energy inside the molten slag. The influences of cup atomizer rotating speed, its diameter and molten slag temperature on the mean slag granule diameter and granules' mass distribution were investigated. The results showed that the mean granule diameter decreases with increasing rotating speed which will lead the slag granules to be far from the cup so as to make their mass distribution more uniform. The rotating speed 1000 r/min is actually a criterion, i.e., the mean granule diameter decreases with increasing cup diameter if lower than it, while the diameter is almost unchanged if higher than it. And the molten slag temperature has no influence on mean granule diameter and mass distribution of granules.

中图分类号: