东北大学学报（自然科学版）

东北大学学报:自然科学版 ›› 2014, Vol. 35 ›› Issue (1): 71-74.DOI: 10.12068/j.issn.1005-3026.2014.01.017

• 材料与冶金 • 上一篇    下一篇

COREX流程的Rist操作线模型及应用分析

湛文龙，吴铿，余盈昌，刘起航   

  1. (北京科技大学 钢铁冶金新技术国家重点实验室， 北京 100083)
  • 收稿日期:2013-04-28 修回日期:2013-04-28 出版日期:2014-01-15 发布日期:2013-07-09
  • 通讯作者: 湛文龙
  • 作者简介:湛文龙(1988-)，男，河南新乡人，北京科技大学博士研究生；吴铿(1951-)，男，辽宁鞍山人，北京科技大学教授，博士生导师.
  • 基金资助:
    国家自然科学基金资助项目(50934007，50874129)；国家高技术研究发展计划项目(2009AA06Z105).

Rist Operating Line Model for COREX Process and Its Application Analysis

ZHAN Wenlong， WU Keng， YU Yingchang， LIU Qihang   

  1. State Key Laboratory of Advanced Metallurgy， University of Science and Technology Beijing， Beijing 100083， China.
  • Received:2013-04-28 Revised:2013-04-28 Online:2014-01-15 Published:2013-07-09
  • Contact: WU Keng
  • About author:-
  • Supported by:
    -

RichHTML

0

PDF (PC)

695

摘要： 借鉴高炉的Rist(里斯特)操作线原理，建立了COREX流程冶炼过程中的物料平衡和热平衡方程.高挥发分的块煤作为其主要燃料，入炉裂解会产生大量H2，因此必须考虑其对上部竖炉和下部熔融气化炉Rist操作线的影响.通过热力学计算，将上、下部操作线模型有机结合起来，建立COREX全流程的Rist操作线数学模型.提出了降低COREX燃料消耗的措施，如提高金属化率、改变入炉燃料结构等.模型计算结果显示，COREX炉在使用低质焦炭代替块煤后，理论上可以节约1747kg燃料，氧气消耗量可降低188%.

关键词: Rist操作线, COREX流程, 物料平衡, 热平衡, 能耗

Abstract: Material balance and heat balance equations in COREX smelting reduction process were established by taking the principle of Rist operating line in blast furnace for reference. As the mainly raw materials， lump coal with high volatile would generate large amounts of H2 during the splitting decomposition in the process. Therefore， the influences of H2 on the Rist operating lines of the upper shaft furnace and the lower melter gasifier must be considered. Through the thermodynamic calculation， the mathematic model of Rist operating lines for the whole COREX process was established by an combination of the upper and the lower operating line. Several methods for decreasing the consumption of COREX fuels were proposed， such as improving melting rate， changing the charging fuel structure and so on. The calculation results showed that when the inferiority coke was used for COREX instead of lump coal， the fuel and oxygen saving reached 1747kg and 188% in theory， respectively.

Key words: Rist operating line, COREX process, material balance, heat balance, energy consumption

中图分类号: