两段式喷煤填充床内煤粉分布规律的试验研究

doi:-

东北大学学报:自然科学版 ›› 2013, Vol. 34 ›› Issue (1): 90-94.DOI: -

两段式喷煤填充床内煤粉分布规律的试验研究

丁智敏，魏国，高强健，沈峰满

(东北大学材料与冶金学院，辽宁沈阳110819)

收稿日期:2012-07-10 修回日期:2012-07-10 出版日期:2013-01-15 发布日期:2013-01-26
通讯作者: 丁智敏
作者简介:丁智敏(1982-)，男，甘肃天水人，东北大学博士研究生；沈峰满(1958-)，男，黑龙江密山人，东北大学教授，博士生导师.
基金资助:
国家自然科学基金资助项目(51074040).

Experimental Study on Distribution of Pulverized Coal in the Packed Bed with Bi-PCI Process

DING Zhi-min， WEI Guo， GAO Qiang-jian， SHEN Feng-man

School of Materials ＆ Metallurgy， Northeastern University， Shenyang 110819， China.

Received:2012-07-10 Revised:2012-07-10 Online:2013-01-15 Published:2013-01-26
Contact: SHEN Feng-man
About author:-
Supported by:
-

摘要/Abstract

摘要： 根据相似原理建立了1∶25的二维冷态填充床模拟高炉喷吹煤粉，通过试验比较了一段式喷煤和两段式喷煤条件下填充床内煤粉的分布规律和压差变化.结果表明:煤粉主要堆积在填充床下部，随高度的增加，煤粉的堆积量呈下降趋势.第二段喷入的煤粉大部分堆积于填充床边缘区域，中心区域堆积的煤粉主要为风口喷入.在喷煤量相同条件下，两段式喷煤时模型高度方向上煤粉分布更加均匀，填充床透气性得到改善；两段式喷煤与一段式喷煤相比，填充床内总压差下降了约29%，主要是填充床下部的压差显著降低；第二段喷入填充床内的煤粉对填充床上部的压差影响不大.

关键词: 高炉, 两段式喷煤, 煤粉分布, 压差, 填充床

Abstract: A two-dimensional packed bed model was established with 1∶25 scale for simulating the PCI (pulverized coal injection)process and the Bi-PCI (bisegment pulverized coal injection)process based on similarity theory. The distributions of powder and pressure were investigated when PCI and Bi-PCI were used respectively. The results showed that the pulverized coal mainly accumulates in the lower part of packed bed， and the accumulation of pulverized coal decreases with increasing height of packed bed. The pulverized coal from the second lance accumulates in the edge region of the packed bed， and the holdup of the mid region is from the tuyere. At the same conditions， the distribution of pulverized coal becomes more uniform at height direction， and the permeability of packed bed is improved when Bi-PCI is adopted. So the pressure drop in packed bed is reduced by 29% compared with the PCI， mainly because the pressure drop significantly decreases in lower part of packed bed. The pulverized coal that have been injected by the secondary lance has little influence on the pressure drop in the upper of the packed bed.

Key words: blast furnace, Bi-PCI, distribution of pulverized coal, pressure drop, packed bed

中图分类号:

TP274

丁智敏，魏国，高强健，沈峰满. 两段式喷煤填充床内煤粉分布规律的试验研究[J]. 东北大学学报:自然科学版, 2013, 34(1): 90-94.

DING Zhi-min， WEI Guo， GAO Qiang-jian， SHEN Feng-man. Experimental Study on Distribution of Pulverized Coal in the Packed Bed with Bi-PCI Process[J]. Journal of Northeastern University:Natural Science, 2013, 34(1): 90-94.

参考文献

[1]Shimizu M，Naito M.Technological progresses and researches on blast furnace ironmaking in the new century［J］.Tetsu-to-Hagané，2006，92(12):694-702.
[2]Nomura S，Callcott T.Maximum rates of pulverized coal injection in ironmaking blast furnaces［J］.ISIJ International，2011，51(7):1033-1043.
[3]The Technical Society，the Iron and Steel Institute of Japan.Production and technology of iron and steel in Japan during 2010［J］.ISIJ International，2011，51(6):857-869.
[4]Yamaguchi K，Ueno H，Tamura K.Maximum injection of pulverized coal into blast furnace through tuyeres with consideration of unburnt char［J］.ISIJ International，1992，32(6):716-724.
[5]Ohno Y，Furukawa T，Matsu-Ura M.Combustion behavior of pulverized coal in a raceway cavity of blast furnace and its application to a large amount injection［J］.ISIJ International，1994，34(8):641-648.
[6]Wu K，Ding R C，Han Q，et al.Research on unconsumed fine coke and pulverized coal of BF dust under different PCI rates in BF at Capital Steel Co［J］.ISIJ International，2010，50(3):390-395.
[7]Maki A，Sakai A，Takagaki N，et al.High rate coal injection of 218 kg/t at Fukuyama No.4 blast furnace［J］.ISIJ International，1996，36(6):650-657.
[8]沙永志，滕飞，曹军.我国炼铁工艺的进步［J］.炼铁，2012，31(1):7-11.(Sha Yong-zhi，Teng Fei，Cao Jun.Progress of ironmaking technology in China［J］.Ironmaking，2012，31(1):7-11.)
[9]Ariyama T，Sato M，Yamakawa Y，et al.Combustion behavior of pulverized coal in tuyere zone of blast furnace and influence of injection lance arrangement on combustibility［J］.ISIJ International，1994，34(6):476-483.
[10]Mathieson J G，Turelove J S，Rogers H.Toward an understanding of coal combustion in blast furnace tuyere injection［J］.Fuel，2005，84(10):1229-1237.
[11]沈峰满，朱蒙，沈岩松.高炉两段式喷吹煤粉新工艺［J］.钢铁，2002，37(10):5-7.(Shen Feng-man，Zhu Meng，Shen Yan-song.Development of bisegment pulverized coal injection into blast furnace as a new process［J］.Iron and Steel，2002，37(10):5-7.)
[12]沈岩松，朱蒙，沈峰满.高炉喷煤新技术［J］.材料与冶金学报，2002，1(2):124-127.(Shen Yan-song，Zhu Meng，Shen Feng-man.New process of bisegment pulverized coal injection in blast furnace［J］.Journal of Materials and Metallurgy，2002，1(2):124-127.)
[13]张先棹.冶金传输原理［M］.北京:冶金工业出版社，2005:181-198.(Zhang Xian-zhao.Metallurgy transport principle［M］.Beijing:Metallurgical Industry Press，2005:181-198.)(上接第89页)呈非线性关系；当冲击载荷为1.5和2.0MPa时，最大等效应力分别为260和281MPa，大于屈服强度，小于抗拉强度，加强筋发生一定的塑性变形，但仍处于安全状态.4) 舱体结构复杂，在冲击载荷作用下，各个区域应力随时间呈强非线性变化，外层钢板和加强筋是舱体危险区域，为防止结构失效需要增加加强筋厚度.无论是正面冲击载荷还是侧面冲击载荷作用，本型号救生舱结构强度完全能满足实际应用要求.

[1]	房晓晴，刘书含，孙文强. 高炉煤气管网水力建模及调度策略[J]. 东北大学学报（自然科学版）, 2023, 44(1): 69-75.
[2]	史本慧，刘炳南，罗志国，邹宗树. 热风在高炉热风围管中流动特性的模拟研究[J]. 东北大学学报（自然科学版）, 2022, 43(5): 755-760.
[3]	吕超，柳静献，孙熙，余振辉. 燃煤飞灰单极荷电对纤维滤料过滤性能的强化[J]. 东北大学学报（自然科学版）, 2021, 42(9): 1335-1340.
[4]	郭永春，郑海燕，胡心光，沈峰满. CaO-SiO₂-MgO-Al₂O₃四元渣系Al₂O₃活度预测模型[J]. 东北大学学报（自然科学版）, 2021, 42(5): 652-657.
[5]	李壮年，储满生，柳政根，李宝峰. 基于机器学习和遗传算法的高炉参数预测与优化[J]. 东北大学学报:自然科学版, 2020, 41(9): 1262-1267.
[6]	刘馨，张卫军，石泉，周乐. 基于数据挖掘与清洗的高炉操作参数优化[J]. 东北大学学报:自然科学版, 2020, 41(8): 1153-1160.
[7]	康月，刘超，张玉柱，姜茂发. 气淬法粒化高炉渣实验研究[J]. 东北大学学报:自然科学版, 2020, 41(2): 212-216.
[8]	杜培培，张玉柱，龙跃. M_k对调质高炉渣制备矿渣棉过程中熔渣性能影响[J]. 东北大学学报:自然科学版, 2019, 40(9): 1279-1283.
[9]	马小刚，陈良玉，李杨. 基于响应面法炉腹异型管铜冷却壁的长寿技术优化[J]. 东北大学学报:自然科学版, 2019, 40(5): 710-715.
[10]	康月，刘超，张玉柱，姜茂发. 气淬法制备高炉渣玻璃微珠的性能[J]. 东北大学学报:自然科学版, 2019, 40(2): 202-206.
[11]	丁智敏，姜鑫，魏国，沈峰满. 软熔带类型对高炉内未燃煤粉分布影响的数值模拟[J]. 东北大学学报:自然科学版, 2018, 39(9): 1242-1247.
[12]	郁肖兵，倪文杰，邹宗树. 富氧高炉综合模型[J]. 东北大学学报:自然科学版, 2018, 39(9): 1248-1253.
[13]	孟繁超，邹宗树. 高炉热储备区温度对煤气利用率的影响[J]. 东北大学学报:自然科学版, 2018, 39(7): 985-989.
[14]	郭贺，沈峰满，张枥，姜鑫. MgO和矿焦混装对烧结矿熔滴性能的影响[J]. 东北大学学报:自然科学版, 2018, 39(7): 990-994.
[15]	郁肖兵，宋文刚，倪文杰，邹宗树. 高炉富氧鼓风对高炉热状态的影响及对策[J]. 东北大学学报:自然科学版, 2018, 39(10): 1413-1417.

两段式喷煤填充床内煤粉分布规律的试验研究

Experimental Study on Distribution of Pulverized Coal in the Packed Bed with Bi-PCI Process

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价