等离子体放电电解制备纳米氧化亚铜

doi:10.12068/j.issn.1005-3026.2019.05.012

东北大学学报:自然科学版 ›› 2019, Vol. 40 ›› Issue (5): 668-672.DOI: 10.12068/j.issn.1005-3026.2019.05.012

等离子体放电电解制备纳米氧化亚铜

沈玲玲¹，赵博¹，徐君莉²，石忠宁¹

(1. 东北大学教育部多金属矿物生态冶金重点实验室，辽宁沈阳110819; 2. 东北大学理学院，辽宁沈阳110819)

收稿日期:2018-04-20 修回日期:2018-04-20 出版日期:2019-05-15 发布日期:2019-05-17
通讯作者: 沈玲玲
作者简介:沈玲玲(1990-)，女，黑龙江海伦人，东北大学博士研究生；石忠宁(1975-)，男，广西都安人，东北大学教授，博士生导师.
基金资助:
中央高校基本科研业务费专项资金资助项目(N172502003)；国家科技攻关计划项目(2017YFC0805101).

Preparation of Nano Cuprous Oxide by Plasma Induced Cathode Discharge Electrolysis

SHEN Ling-ling¹， ZHAO Bo¹， XU Jun-li²， SHI Zhong-ning¹

1. Key Laboratory for Ecological Metallurgy of Multimetallic Mineral， Ministry of Education， Northeastern University， Shenyang 110819， China; 2. School of Sciences， Northeastern University， Shenyang 110819， China.

Received:2018-04-20 Revised:2018-04-20 Online:2019-05-15 Published:2019-05-17
Contact: SHI Zhong-ning
About author:-
Supported by:
-

摘要/Abstract

摘要： 采用非接触阴极等离子体放电电解法在硫酸铜水溶液中制备纳米氧化亚铜，分析不同浓度、放电电压和电解时间等因素对产物形貌及其组成的影响.结果表明:增加硫酸铜浓度有利于产物中氧化亚铜的形成;延长电解时间会使颗粒发生聚合，尺寸由100nm增大至400nm;电解电压升高，颗粒尺寸从200nm减小到40nm.发射光谱分析表明发光区域存在大量激发态铜原子和羟基自由基，构成了Cu₂O的形成机理.理论计算表明，等离子体电子激发温度为 9563K，电场强度为2.4×10⁵V/m，弧柱射流速度为73m/s.

关键词: 等离子体电解, 电化学反应, 自由基, 纳米氧化亚铜, 形成机理

Abstract: Nano cuprous oxide(Cu₂O)powders were prepared by plasma induced cathode discharge electrolysis in CuSO₄ solution， and the components and morphology of the prepared particles were investigated by various concentrations， electrolysis voltage and time. The results showed that a higher concentration of solution had a positive effect on the formation of Cu₂O phase. As the discharge time extended， the particles aggregated and the size increased from 100nm to 400nm. Increasing the voltage was beneficial for the refinement of particles from 200nm to 40nm.Emission spectrum analysis indicated that there existed hydroxyl radicals and Cu atoms in plasma emission area， which was suggested that the formation mechanism of Cu₂O. Theoretical calculation showed that excitation temperature， the electric field intensity and the arc column jet velocity was 9563K， 2.4×10⁵V/m， and 73m/s， respectivively.

Key words: plasma electrolysis, electrochemistry reaction, free radicals, nano cuprous oxide, formation mechanism

中图分类号:

O646

沈玲玲，赵博，徐君莉，石忠宁. 等离子体放电电解制备纳米氧化亚铜[J]. 东北大学学报:自然科学版, 2019, 40(5): 668-672.

SHEN Ling-ling， ZHAO Bo， XU Jun-li， SHI Zhong-ning. Preparation of Nano Cuprous Oxide by Plasma Induced Cathode Discharge Electrolysis[J]. Journal of Northeastern University Natural Science, 2019, 40(5): 668-672.

参考文献

[1]Joseph S，Kamath P V.Growth of Cu₂O nanocrystals on stainless steel substrates by electrodeposition in presence of surfactants［J］.Journal of the Electrochemical Society，2009，156(10):143-147.
[2]李如，闫雪峰，于良民，等.氧化亚铜微/纳米结构的形貌可控制备及光催化和防污性能［J］.无机化学学报，2014，30(10):2258-2269.(Li Ru，Yan Xue-feng，Yu Liang-min，et al.Dependence of micro/nano-Cu₂O structures:controlled morphology synthesis，and photocatalytic and antifouling property ［J］.Chinese Journal of Inorganic Chemistry，2014，30(10):2258-2269.)
[3]刘儒平，杜利东，岳钊，等.Cu₂O纳米晶制备及其在乙醇气体传感器中的应用［J］.传感器与微系统，2013，32(12):138-141.(Liu Ru-ping，Du Li-dong，Yue Zhao，et al.Preparation of Cu₂O nanocrystalline and its application in ethanol gas sensor ［J］.Transducer and Microsystem Technologies，2013，32(12):138-141.)
[4]Yin H，Wang X，Wang L，et al.Cu₂O/TiO₂heterostructured hollow sphere with enhanced visible light photocatalytic activity［J］.Materials Research Bulletin，2015，72:76-183.
[5]Das K，De S.Optical and photoconductivity studies of Cu₂O nanowires synthesized by solvothermal method ［J］.Journal of Luminescence.2009，129(9):1015-1022.
[6]Goli M，Haratizadeh H，Abrishami M E.Growth of flower-like copper oxide nanostructures by glow discharge in water［J］.Ceramics International，2014，40:16071-16075.
[7]Yao W T，Yu S H，Zhou Y，et al.Formation of uniform CuO nanorods by spontaneous aggregation:selective synthesis of CuO，Cu₂O，and Cu nanoparticles by a solid-liquid phase arc discharge process［J］.Journal of Physical Chemistry B，2005，109(29):14011-14016.
[8]Liu J D，He B B，Chen Q，et al.Plasma electrochemical synthesis of cuprous oxide nanoparticles and their risible-light photo catalytic effect［J］.Electrochimica Acta，2016，222:1677-1681.
[9]Lu Y，Ren Z，Yuan H，et al.Atmospheric-pressure microplasma as anode for rapid and simple electrochemical deposition of copper and cuprous oxide nanostructures ［J］.Rsc Advances，2015，77(5):62619-62623.
[10]Oishi T，Kawamura H，Ito Y.Formation and size control of titanium particles by cathode discharge electrolysis of molten chloride［J］.Journal of Applied Electrochemistry，2002，32(7):819-824.

等离子体放电电解制备纳米氧化亚铜

Preparation of Nano Cuprous Oxide by Plasma Induced Cathode Discharge Electrolysis

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 10

编辑推荐

Metrics

本文评价

[1]	尚融雪，高俊豪，杨悦，李刚. CO₂/N₂稀释对H₂/CH₄层流火焰传播特性的影响[J]. 东北大学学报:自然科学版, 2020, 41(9): 1321-1327.
[2]	谢翌，钟晨，谭传智，刘校兵. MILD燃烧条件下掺氢比对甲烷-氢气湍流扩散火焰的影响[J]. 东北大学学报:自然科学版, 2017, 38(8): 1148-1153.
[3]	郭洪光，刘杨，张永丽. 紫外激活过硫酸钠降解环境雌激素17β-雌二醇分析[J]. 东北大学学报:自然科学版, 2016, 37(6): 880-885.
[4]	马诗敏，徐新阳，陈熙，郭晓东. 松辽西部地区高氟地下水形成机理[J]. 东北大学学报:自然科学版, 2014, 35(10): 1487-1491.
[5]	王余莲，印万忠，钟文兴，侯英. 花状五水合碳酸镁的制备及形成机理研究[J]. 东北大学学报（自然科学版）, 2013, 34(12): 1783-1786.
[6]	胡筱敏;孙兆楠;董嫦娥;熊英禹;. 周期换向电解过程中羟基自由基的产生及测定[J]. 东北大学学报(自然科学版), 2012, 33(12): 1774-1777.
[7]	高泰荫;丛琦;赵永坚;栗自彬;信一兵. H_2-O_2混气系着火“半岛”现象的数值验证[J]. 东北大学学报(自然科学版), 2000, 21(5): 543-546.
[8]	高泰荫;信一兵;高越. 无声放电场中OH自由基发生及其氧化碳烟的动力学模拟[J]. 东北大学学报:自然科学版, 1997, 18(6): 5--.
[9]	高泰荫;信一兵;黄军涛. 无声放电场作用下产生OH自由基的实验研究[J]. 东北大学学报:自然科学版, 1997, 18(5): 5--.
[10]	张明杰;邱竹贤. 冰晶石-氧化铝熔液电解中阳极过程的研究[J]. 东北大学学报:自然科学版, 1984, 5(1): 49-59+133.