冷却风量影响烧结余热竖罐回收中火用传递系数实验研究

doi:10.12068/j.issn.1005-3026.2014.05.023

东北大学学报:自然科学版 ›› 2014, Vol. 35 ›› Issue (5): 708-711.DOI: 10.12068/j.issn.1005-3026.2014.05.023

冷却风量影响烧结余热竖罐回收中火用传递系数实验研究

董辉，冯军胜，李磊，王爱华

(东北大学国家环境保护生态工业重点实验室，辽宁沈阳110819)

收稿日期:2013-09-06 修回日期:2013-09-06 出版日期:2014-05-15 发布日期:2014-08-18
通讯作者: 董辉
作者简介:董辉(1969-)，男，辽宁沈阳人，东北大学教授.
基金资助:
国家自然科学基金资助项目(51274065).

Experimental Study on Exergy Transfer Coefficient Affected by Cooling Air Volume in Vertical Tank of Waste Heat Recovery

DONG Hui， FENG Junsheng， LI Lei， WANG Aihua

SEPA Key Laboratory on Ecoindustry， Northeastern University， Shenyang 110819， China.

Received:2013-09-06 Revised:2013-09-06 Online:2014-05-15 Published:2014-08-18
Contact: FENG Junsheng
About author:-
Supported by:
-

摘要/Abstract

摘要： 将对流换热器和填充床中火用传递系数的概念引入到竖罐式余热回收工艺中，推导出烧结移动床层火用传递系数公式;在自制的气固传热实验装置上，测定不同工况下罐体料层内气固传热过程的相关数据，研究冷却风量对烧结床层火用传递系数的影响.研究结果表明:冷却风量不变时，平均物理火用传递系数hex，m随矿温的升高而增大;相同平均矿温条件下，当hex，m大于0时，hex，m随冷却风量的增加而增大;当hex，m小于0时，会导致竖罐出口冷风火用值减少，对强化气固换热不利.

关键词: 烧结, 余热, 回收, 气固换热, 火用传递系数

Abstract: The exergy transfer coefficient formula in sintering moving bed was derived by introducing the concept of the exergy transfer coefficient in the convection heat exchanger and fixed bed into the vertical tank of sintering waste heat recovery. The relevant data of gassolid transfer process under different conditions in sinter bed of vertical tank was measured in homemade gassolid heat transfer experiment device， and the effect of the cooling air volume on the exergy transfer coefficient in sinter bed was investigated. The results showed that the average physical exergy transfer coefficient hex，m increased with the increase of the ore temperature when the cooling air volume was constant. At the same average ore temperature，when hex，m was greater than zero， it increased with the increase of the cooling air volume; when hex，m is less than zero it reduced air cooling exergy value of vertical tank outlet and adversed to strengthen gassolid heat transfer.

Key words: sinter, waste heat, recovery, gassolid heat transfer, exergy transfer coefficient

中图分类号:

TK11+5

董辉，冯军胜，李磊，王爱华. 冷却风量影响烧结余热竖罐回收中火用传递系数实验研究[J]. 东北大学学报:自然科学版, 2014, 35(5): 708-711.

DONG Hui， FENG Junsheng， LI Lei， WANG Aihua. Experimental Study on Exergy Transfer Coefficient Affected by Cooling Air Volume in Vertical Tank of Waste Heat Recovery[J]. Journal of Northeastern University Natural Science, 2014, 35(5): 708-711.

参考文献

[1] 董辉，赵勇，蔡九菊，等.烧结/冷却系统漏风问题研究［J］.钢铁，2012，47(1):95/99.(Dong Hui，Zhao Yong，Cai Jiuju，et al.On the air leakage problem in sintering cooling system［J］.Iron and Steel，2012，47(1):95/99.)
[2] 蔡九菊，董辉.烧结过程余热资源的竖罐式回收与利用方法及其装置:中国，200910187381.8［P］.2009/09/15.(Cai Jiuju，Dong Hui.The method and device of sintering waste heat recovery and utilization with vertical tank:China，200910187381.8［P］.2009/09/15.)
[3] Errera M R，Milanez L F.Thermodynamic analysis of a coke dry quenching unit［J］.Energy Conversion & Management，2000，41(2):109/127.
[4] Dong H，Jia F R，Cai J J，et al.Experimental investigation on the drying process of the sinter mixture［J］.Powder Technology，2012，218:1/4.
[5] Wu S Y，Li Y R.Chen R，et al.Exergy transfer characteristics of forced convective heat transfer through a duct with constant wall temperature［J］.Energy，2007，32(12):2385/2395.
[6] Wu S Y，Chen Y，Li Y R，et al.Exergy transfer characteristics of forced convective heat transfer through a duct with constant wall heat flux［J］.Energy，2007，32(5):686/696.
[7] Kurtbas，，Celik N，Diner .Exergy transfer in a porous rectangular channel［J］.Energy，2010，35(1):451/460.
[8] Prommas R，Keangin P，Rattanadecho P.Energy and exergy analyses in convective drying process of multilayered porous packed bed［J］.International Communications in Heat and Mass Transfer，2010，37(8):1106/1114.
[9] Vicente P G，Garcia A，Viedma A.Mixed convection heat transfer and isothermal pressure drop in corrugated tubes for laminar and transition flow［J］.International Communications in Heat and Mass Transfer，2004，31(5):651/662.
[10] Demirel Y，Sandler S I.Linearnonequilibrium thermodynamics theory for coupled heat and mass transport［J］.International Journal of Heat and Mass Transfer，2001，44(13):2439/2451.

[1]	李丽君，刘乙铎，程富. 政府补贴和第三方回收下的产品回收合作策略[J]. 东北大学学报（自然科学版）, 2023, 44(3): 440-447.
[2]	陈猛，王瑜婷，曹宇新. 回收轮胎聚合物纤维混凝土干缩性能研究[J]. 东北大学学报（自然科学版）, 2023, 44(1): 123-129.
[3]	陈猛，王瑜婷，陶云霄，王浩. 基于分形理论研究RTSF混凝土冲击压缩性能[J]. 东北大学学报（自然科学版）, 2022, 43(2): 266-273.
[4]	祁腾飞，黄军，孙俊杰，张永杰. 布料方式对竖冷炉内烧结矿偏析及气流分布的影响[J]. 东北大学学报（自然科学版）, 2022, 43(10): 1422-1429.
[5]	王长军，于洋，李宝宽，刘雪林. 钢带烧结料层的干燥氧化过程仿真[J]. 东北大学学报（自然科学版）, 2021, 42(9): 1282-1289.
[6]	周素莹，丁学勇，薛向欣，杨合. 磷酸铵镁结晶法高效回收提钒废水中的高浓度氨氮[J]. 东北大学学报（自然科学版）, 2021, 42(6): 789-794.
[7]	李坤蒙，李元辉，王者超，熊志朋. 硬岩采场新型预应力膨胀支柱的研发及应用[J]. 东北大学学报（自然科学版）, 2021, 42(2): 213-219.
[8]	周浩宇，范晓慧，李谦，甘敏. 氢系气体喷吹对烧结污染物释放的影响规律[J]. 东北大学学报（自然科学版）, 2021, 42(2): 260-267.
[9]	鲍君峰，于月光，贾成厂. ZrO₂添加量对等离子放电烧结制备WC-6Co组织和性能的影响[J]. 东北大学学报（自然科学版）, 2021, 42(1): 43-48.
[10]	陈猛，刘阳波，陶云霄，王浩. 回收轮胎聚合物纤维混凝土性能试验研究[J]. 东北大学学报:自然科学版, 2020, 41(6): 870-874.
[11]	刘春怡，尤天慧，曹兵兵. 考虑风险与资金约束的闭环供应链定价与回收决策[J]. 东北大学学报:自然科学版, 2020, 41(6): 902-908.
[12]	张立恒，高子先，汤卫东，薛向欣. w(TiO₂)对高铬型钒钛磁铁矿烧结矿冶金性能的影响[J]. 东北大学学报:自然科学版, 2020, 41(11): 1667-1672.
[13]	朱小平, 孙树臣, 涂赣峰, 孙挺. 熔融铁粉捕集回收废催化剂中金属钯[J]. 东北大学学报（自然科学版）, 2020, 41(10): 1410-1415.
[14]	岳强，薛梦，张钰洁，栗树朋. 基于系统动力学模型的中国汽车工业废杂铝回收分析[J]. 东北大学学报:自然科学版, 2020, 41(1): 68-73.
[15]	公彦兵，孙俊民，张廷安，吕国志. 高铝粉煤灰拜耳法溶出渣碱回收[J]. 东北大学学报:自然科学版, 2019, 40(3): 345-350.

冷却风量影响烧结余热竖罐回收中火用传递系数实验研究

Experimental Study on Exergy Transfer Coefficient Affected by Cooling Air Volume in Vertical Tank of Waste Heat Recovery

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价